Last post on Mar 08, 2013 at 10:02 PM
You are in the Chevrolet Colorado and GMC Canyon
What is this discussion about?
Chevrolet Colorado, GMC Canyon, Fuel System, Truck
#3 of 46 Re: gas tank pressure [poncho167]
Apr 16, 2008 (9:47 am)
i have talked to a few people and they said it could be my "vent control valve" is stuck shut. Any feedback on this would be appreciated and if so any clue where that is located?thanks
#4 of 46 Re: gas tank pressure [redshamrock]
Apr 19, 2008 (6:13 am)
I don't have a Cobalt, but the vent control valve that I think they are referring to should be connected to your air filter system. I could be wrong but there is a valve door on my trucks air cleaner ducting that opens and closes. Mine currently is always in the open position because it doesn't really matter in my truck. There is also an exhaust gas container that contains charcoal for excess fuel vapor flow but this shouldn't be related. I can't say anymore. The only other valves that are related to gas but maybe not in your situation is the EGR (exhaust gas recirculator) valve on my S10's intake manifold.
May 07, 2008 (3:34 pm)
my dealer told me my 05 colorado needs a fuel filter for $70= . i saw one on internet for 16.00 and wounder how hard it is to relpace, is it inside the gas tank or just on the fuel line thanks..
May 08, 2008 (2:57 pm)
Its easy to change on front of tank inline ten min job.
#7 of 46 Re: gas tank pressure [poncho167]
May 10, 2008 (7:30 am)
I meant Colorado.
May 10, 2008 (11:20 am)
I have 5 crew cab 4wd did mine in ten min.
#9 of 46 Re: fuel filter [dick28540]
Jun 13, 2008 (4:51 pm)
Your filter is just behind your gaz tank
push type clip no special toll
hope that help you
Jun 16, 2008 (7:55 pm)
I got some problem with my electric purge valve
when stock close , not able to fill my truck (20 minutes to fill 15 gallons)
when valve open and stick open when you stop the truck there big odors of gas
did somebody replace the valve on the canister
it's located the rear crossmember in front of the spare
#11 of 46 Gas tank overflows when filling
Feb 06, 2009 (3:24 pm)
My 2004 5 cylinder Colorado has 75,000 miles on it. About two months ago when I was filling it with gas, the gas didn,t shut off and it overflowed. I've caught it doing this a couple of times since. Also, when I start it after getting gas, it cranks like it doesn't want to start. It does start but takes a long time compared to other starts. The service engine soon light is on and my mechanic says it's because the new fuel cap doesn't seal properly because the gas tube is bent due to the gas pump nozzles resting on it. This I understand but don't understand why it overflows and starts so hard.
#12 of 46 Re: Gas tank overflows when filling [mikeof48]
Feb 14, 2009 (6:12 am)
This doesn't sound right. As far as I know, if the gas pump doesn't shut off it's because THE GAS PUMP'S nozzle isn't set correctly, allowing it to run on after detecting "backflow". That's a safety measure designed into the pump.
If your gas cap isn't sealing correctly, I could see how that might cause a hard start, as the tank won't pressurize correctly. However, I doubt that the weight of the nozzle alone, would deform the filler neck. On the rare chance that it did, it wouldn't be a hard job to replace the filler neck. It isn't part of the tank. It's a seperate piece that attaches to the truck's bed with 3-4 screws, and a short length of rubber tubing connects it to the tank. If the dealer won't warranty it for you, it shouldn't be an expensive fix.