Last post on Dec 05, 2013 at 11:56 AM
You are in the Ford Windstar
What is this discussion about?
Ford Windstar, Car Safety, Van
#58 of 75 Re: 2001 Windstar chirp and die [zachsdad777]
Aug 29, 2012 (3:38 am)
If any of your symptoms include a noise that sounds like a fan belt squeal, then your issue is the crank sensor. It has a bushing that goes dry. This causes the squeal noise and throws your engine timing off which will sputter and stall the engine. If you want a way to test that crank sensor, I would take the black cap off and spray some lubricant into this area.....that should loosen that bushing and you should see an immediate improvement. By the way, when you take that black cap off, you are looking at the very top of the crank sensor assembly. If you remove the whole assembly, it is about 10 inches long and goes deep into the engine area. The busing that goes bad is almost at the very top of this assembly and a shot of WD-40 sprayed into it will tell you if this sensor is your culprit. Best of luck to you, Jim in Delaware.
#59 of 75 Re: 2001 Windstar chirp and die [delawarejim]
Aug 29, 2012 (7:18 am)
Thanks, Jim. In my heart, I was always leaning toward the crank sensor, because of the short squeal associated with the stall. I kind of figured that the problem would not present itself at higher speed, because a bad bushing would be less apparent due to the higher RPM. What I was struggling with was the fact that once the car is warmed up, it seems fine, no matter what RPM. This issue only seems to occur during the first 10 minutes after a cold start. That fact led me to think IAC or some other malfunction in the throttle body. I threw away $28 at Autozone the other day, as the 2 "pro's" just KNEW it was the TPS. Didn't do a thing. I am all too happy to swap out sensors and gadgets at $50 a pop as they are easy, but am not looking forward to getting all greasy and icky replacing the synchronizer. I am going to do it, though. I will post results in hopes that someone else may be helped, although one assumes all the issues in this forum have been resolved, based on the age of the posts. Thanks again! Tim
#60 of 75 1999 for winstar
Sep 03, 2012 (11:28 am)
this van will stall after running fine for aprrox. 45 minutes, sometimes will start right back up. usually you have wait about an hour for it to restart, turns over fine, what the ???? any answers?
#61 of 75 ford windstar starts and dies
Nov 09, 2012 (4:20 pm)
hi we have a 98 ford windstar lx, when we go to start it up the engine dies, no check engine light is on, we have had the coil spring replaced, withe the intake manafold replaced, no vacume leak, fuel filter replaced, brand new spark plugs put in as well, but it does the same thing still
#62 of 75 99 ford windstar 3.8L
Dec 04, 2012 (11:29 am)
hello. i am new to this so please excuse me.. i have a 99 ford windstar that will click multiple times but will not start. we have replaced several things on the van, but the other the car would only click and wouldn't start.. i finally got it today to click multiple times.. (don't ask me how).. i am thinking i am getting a bad connection on my battery or the starter is bad.. not real sure..
the starter cable going from the starter to the battery had pulled off of the starter which is what made it not start before hand.. we fixed that but yet it still won't start
#63 of 75 Re: Van stalls intermittently along with belt squeal [rkarki]
Dec 07, 2012 (6:53 am)
I have a 2003 Windstar that has had the same problem...we changed the "crankshaft sensor" and it continued, then changed the "camshaft sensor" and it continued, then changed the "camshaft synchronizer". It has run 7 days without a problem...knock on wood !! good luck Jay
#64 of 75 Re: 99 ford windstar 3.8L [kristina0612]
Dec 19, 2012 (9:01 am)
Check your relay fuse. My van did that i could kick start it by sticking a screwdriver on the starter which I dont recomend if you dont know how. The relay fuse had blown.
#65 of 75 Re: Windstar dies while driving [jenerikj]
Jul 09, 2013 (6:30 pm)
I have a 96 Ford Windstar, only 5800 miles and it stalls all the time when I remove my foot from the gas. Took it to Ford Dealership and they replaced idle air control valve and performed fuel induction cleaning, it did no good, they said they had no idea why it was doing this and to come get it, they refunded the 300 plus dollars they charged but I still can't drive it. Does anyone have any ideas or what else to try, if FORD Doesnt know, who the heck does???? HELP PLEASE
#66 of 75 Re: Windstar dies while driving [cimarronpass]
Aug 30, 2013 (12:45 pm)
have you repaired this van ???????
#67 of 75 Re: Windstar dies while driving [scjibberjaws49]
Aug 30, 2013 (3:12 pm)
No, It gradually deteriorated tot he point where sometimes I can get it to run but it acts like it is running on two cylinders. I think it is the control mounted under the battery holder since it is exposed to splashing from the front left tire. I say it was because I have given up on it and it is sitting in my driveway waiting to junked out or donated.