Chevrolet Malibu Maxx Rattles, Bumps & Squeaks

12 messages, Last post on Dec 20, 2007 at 7:50 AM

You are in the Chevrolet Malibu Maxx Forum. Your Host is pf_flyer

What is this discussion about? Chevrolet Malibu Maxx, Hatchback

Is your Maxx making a strange noise that you can't quite figure out? This is the place to begin your quest for a solution!

Outline

Messages Page 2 of 2: 1; 2; Prev; Next; Last

#6 of 12 Malibu Maxx-Rattles by rmill777 Dec 01, 2007 (10:06 am)
I think the annoying fluttering rattle coming from the ventilation area of my Malibu Maxx is solved. I have two 2006 Malibu Maxxs, both had the rattle. Following Popodolis suggestion I checked under the hood and noted that just under the rubber molding that seals the windshield end of the hood there is a joint in the plastic enclosure for the air system. About two feet in from each fender the plastic showed an opening that was wider than the rest of the joint. For a temporary fix I just took a piece of 2" wide plastic tape that you seal boxes with and covered the joint opening at the point where it seemed to have opened up. Went for a test drive. Voila, no more rattle. When my temporary fix loosens up I'll probably just run a bead of silicone down the joint to seal it. Thanks Popodolis.
#7 of 12 spelling by rmill777 Dec 02, 2007 (7:37 am)
Sorry I mispelled your name popadopolis. My brain doesn't stay attached to my keyboard. But I still thank you. Replies to this message: popadopolis (Dec 03, 2007 7:11 am)
#8 of 12 Re: spelling [rmill777] by popadopolis Dec 03, 2007 (7:11 am)
Replying to: rmill777 (Dec 02, 2007 7:37 am) Not a problem rmill777. I know the brain/finger thing well. Tends to get worst with age!!! I'm just glad to help and also glad you solved your problem. Have a great day.
#9 of 12 rattle by fezaz Dec 03, 2007 (8:15 am)
I still have the rattle, I'll have to try that fix.
#10 of 12 Wind Rattle by rmill777 Dec 06, 2007 (9:47 am)
I thought I had cured my rattle on my two 2006 Maxxs but they came back but the tape I put on quieted them down considerably. I guess I'll have to get to the dealer for a cure.
#11 of 12 Wind Rattle-Malibu Maxx by rmill777 Dec 16, 2007 (8:06 am)
I took my Malibu Maxx to the dealer to fix the annoying, vibrating rattle. He found Bulletin 07-08-111-001 which advised putting double sided tape on wiper cowl. He installed double sided tape and the rattle is gone.
#12 of 12 Malibu Maxx leaking by sean418 Dec 20, 2007 (7:50 am)
Has anyone had a problem with leaks from the Maxx windshield or other windows? I am having a problem with my 2004 Maxx where there is a leak when it rains heavy. I have not found it when going through a car wash, but if there is a heavy rain, there is condensation inside the windows, especially the windshield. I have also had wet carpet around the rear left passenger carpet area. Has anyone experienced this problem?