Ask the Car People.SM


Ford Expedition Electrical Problems

279 messages,  Last post on Apr 29, 2013 at 9:31 AM

You are in the Ford Expedition Forum.

What is this discussion about? Ford Expedition, Electrical, SUV

Messages Page 5 of 29

#38 of 279 Help with Relay electrical issues 2003 Expedition by kearwood

May 01, 2008 (5:23 am)

I have a ford expedition that has four problems
one being a relay relay but know nothing about relays. My expedition has the door ajar on the message center but no doors are ajar. This in turn causes the lights to not go out and the door locks to not lock automatically and when you take the key out of the ignition the radio goes off instead of staying on until you open the door.
  
Secondly, we also have problems with the cruise control not working.
Thirdly, the foot pedal that moves the pedals forward or backward.
Last the cd player keeps the cd and will not release it I push the eject but it shows no cd but I know for a fact there is a cd in area 1 and a cd in area 2.
  
any help would be appreciated.

#39 of 279 Re: Help with Relay electrical issues 2003 Expedition [kearwood] by autoboy16

May 05, 2008 (3:35 am)

Replying to: kearwood (May 01, 2008 5:23 am)
Our 2003 Ford Expedition has a few electrical Gremlins too...
 
1:The 7-8 and 9-0 Keypad buttons will not work anymore.
 
2:The Truck will not turn over. When the Key is turned to the ON position, it just makes a loud buzzing sound from the Glovebox and it will not even turn over tostart.
 
3: The interior lights won't turn off. In the Computer screen, it says Door Ajar but all doors are closed. The lights soon go off... Then comes back on!! Eventually goes off and then comes back on and the cycle continues. At night, this becomes very distracting...
 
4:Rear Driver Window will power down, but not power back up unless pressed from drivers seat.

#40 of 279 2004 expedition electrical problem by jaxyjen

Jun 01, 2008 (12:36 pm)

My expedition started freaking out. Dashboard lights blinking on and off after turning the vehicle off and removing the keys. Also locks would pop up and down and interior map lights would surge bright to dim. This would continue until battery dies or it I drive it around. Problem is intermitten and dealer has no clue. Have been billed for the replacement of battey & alternator (1st try from dealer). And the replacement of fuse box (2nd trip to dealer). There has been no rain and my carpets are NOT wet. What could be causing this?? Also fuse for ondemand map lights (spot 24) - I have to pull that fuse completely otherwirse interior lights stay on permantly.

#41 of 279 2003 Ford Expedition, feeling the electrical pain by kd4kmz

Jun 01, 2008 (9:07 pm)

I feel for all you bloggers on teh forum, I have the similar issue, but I trace it to the radio first, it owuld go off on its own and i can hear the realy click in teh fuse box, then I started getting the door ajar, soetimes with or withoiiut the dome lights comiong on or hearing the doors unlock. I have read blogs that say this is water related, I am dry as a bone in sunny Texas with temps in the 90's, so this leads me to believe that I either have a relay going bas or that the issue is in teh VSM vehicle security Module as there is a direct tie to this, I am just getting ready to pay this off as soon as the income tax comes in and will take it to the dealer, I am betting that it is one of the 300 series relays that I cannot find, or it is the VSM, if anyone figures this out before I spend the big bucks let me know, kd4kmyhoo.com Ron Thanks

#42 of 279 Re: Help with Relay electrical issues 2003 Expedition [autoboy16] by tammymac

Jun 04, 2008 (9:58 pm)

Replying to: autoboy16 (May 05, 2008 3:35 am)
2:The Truck will not turn over. When the Key is turned to the ON position, it just makes a loud buzzing sound from the Glovebox and it will not even turn over tostart.
 
I had to replace my relay switch which is on passenger side below the glove box. It worked for months, then weeks and now days. For a temporary fix you can replace the relay switch. I am trying to find a permanet fix.

#43 of 279 Re: 2001 Expedition electrical problems [pgn839] by kd4kmz

Jun 09, 2008 (10:33 am)

Replying to: pgn839 (Dec 26, 2007 12:43 pm)
I just wanted to add from my recent experience and troublshooting. it is not always the window seal, it is just moisture in general. I live in very dry conditions and have to run the airconditioner all the time, it is the sweat from the airconditioner chambers that has been causing my problem where the moisture builds up under the dash in the cab and drips down onto the Fusebox assembly which of course houses the GEM on the back side very small part of the module, I finally found it, last weak when I heard the sound of frying like when water drops on to a hot stove, and at that point the Radio wentout and the windows would not work, I turned off the air and suffered the heat and let the truck dry out, everything worked, the very neck time I used the airconditioner after it built up moisure under the dash walla the problem was back, I am going to reove teh unit and see if there is a way to seal it so it doesn't let the moisture in, may be as simple as putting a little insulation of some sorts , once I do, I will repost the blog, maybe I can save allot of people moneythat Ford is absorbing from others Ron kd4kmzyahoo.com

#44 of 279 2004 Electrical Problems - continued by jaxyjen

Jun 09, 2008 (8:24 pm)

Back to the dealer a 4th time with this SUV. Told of yet another part more $$ to fix problem - they are now approx 75% sure this will do it. Yeah RIGHT!
 
I've have heard for the last time how service tech can not make car act up and they've "never heard of anything like this" before. I guess non of them service techs, dealers or Ford pay any attention to the communications (emails sent to them or blogs)
 
If they can't repeat problem.... Can I sell car without problems??
 
 
 
If anyone has listing and info on previous parts problems fixes, I am printing tons of pages out to take with me to the dealer to show them of the "non-existing" problems with electrical system(s).

#45 of 279 Possessed Expedition by jrsfam

Jun 19, 2008 (3:16 am)

When I start my 2000 Ford Expedition by dashboard lights and radio display flicker off and on. My driver side window goes down on its own. Sometimes my ac turns off. Now my dome lights stay on while I am driving and even after I turn by car off.
I have replaced the battery and alternator. My mechanic said my alarm system was malfunctioning so he disconnected it. That did not solve the problem. And off course when I try to show my mechanic what is wrong it doesn't do it. Very frustrated !!!!!!

#46 of 279 Re: Help with Relay electrical issues 2003 Expedition [tammymac] by autoboy16

Jun 21, 2008 (10:27 am)

Replying to: tammymac (Jun 04, 2008 9:58 pm)
I forgot to respond back! Thanks! Thats exactly what it was!! So far, only the other issues remain. We're tackling them one at a time! Next is the annoying door ajar!
 
I love driving the Expy but gas is really becoming a threat. We put in $75 and only got 3quarters worth of gas... But the MPG is improving! I was driving and I was getting nearly 16mpg City! Big Baby never revs but it is a beast when it does!
 
As much as we hate paying for gas... and we HATE, we love our truck more! Being paid off only adds insult to injury!
 
-Cj

#47 of 279 Re: Help with Relay electrical issues 2003 Expedition [autoboy16] by kd4kmz

Jun 21, 2008 (12:54 pm)

Replying to: autoboy16 (Jun 21, 2008 10:27 am)
Get some WD40 and go around to all your doors and spary the door connector area, the door adjar switches are in there nowspray and open and close each door several times to get the lubricant up in there and your problem may go away, mine did no more door adjar or interior light activation on thier own, amazing that everything went hay wire around the same time and I kept reading it was one thing it is multiple things. ALready replaced teh heat and cold attuator in the rear now the roof and floor attuator is out, Replaced the Vehicle secirity module that was fun, moissture from teh aircondition sweating into the box was causing a positive short that when wet was shutting off my radio and woulnd't let the windows come down, I heard it was water from teh window seal, but I sprayed the window and roof exceissively and never found the water penetrating and then realized it never happened in teh winter or when the AC wasn't on or had been on where moisture had built up, after a well the contacts will start to stick and you end up changing the Vehicle secutiy module and the fuse box assembly , because the GEm is on teh BAck of the Fuse Box and teh contacts will stay stuck periodically.

Messages Page 5 of 29

To POST a message, please Sign In.

Advertisement

Browse by Category

Browse by Vehicle
   View All Vehicles

Browse by Board
Browse by Topic
View All Topics

Edmunds Community

Advertisement