You are here: Forums Pickups Chevrolet S-10 & GMC S15 Sonoma Chevy S10 - GMC S15 and Sonoma Fuel Pump and Fuel System

Chevy S10 - GMC S15 and Sonoma Fuel Pump and Fuel System

49 messages,  Last post on Nov 16, 2009 at 1:02 PM

You are in the Chevrolet S-10 & GMC S15 Sonoma Forum. Your Host is kcram

What is this discussion about? Chevrolet S-10, GMC Sonoma, Truck

Messages Page 5 of 6 1 2 3 4 5 6 Prev Next Last

Go To Msg # Search This Discussion

#36 of 49 fuel pressure regulator install ? by ggrghrtmn Jan 24, 2009 (3:33 am)
Does anyone know where i can find info on how to install a fuel pressure regulator in a 99 s10.4.3 v6.
#37 of 49 Is it the fuel pump? by Jay1964 Feb 06, 2009 (8:30 am)
2001 S-10 4.3L two seperate occasions would not start this winter.Both times when put in the building to warm up,eventually started.Faithfully have used Heet in every load of gas,and has occured at varying fuel levels.Had it towed the second time and the repair shop wanted $1100 to repair,claiming the pump itself was $600.By the time I figured out where to get the cash for the repair,they called and said it starts everytime now,so I didn't get it replaced.They also siad they couldn't guarantee the fuel pump is the issue.I have never had a problem in the past,including last winter.This winter has been especially cold,but started on days at -5,and then when it was 12,it didn't.Frustrating as it nows sits,will not start,it is 33 out and should go.Will crank but is getting no fuel.Any ideas?
#38 of 49 fuel pump problem by bbrianb Mar 16, 2009 (8:39 am)
I have a 2002 gmc sonoma with 4.3 liter motor. I have been having problems with the fuel pump not kicking on. I used to be able to hit the hitch with a hammer causing it to start. I thought it was a bad motor in the pump. I replaced the pump assembly and fuel filter. Now it still doesn't come on. I have checked all of the fuses and the relay. All are good. I wonder where to look next. Replies to this message: gonogo (Mar 17, 2009 8:18 am)
#39 of 49 Re: fuel pump problem [bbrianb] by gonogo Mar 17, 2009 (8:18 am)
Replying to: bbrianb (Mar 16, 2009 8:39 am) You need a wiring schematic and a 12 volt test light. You need to find out where you are not getting 12 volts. The pump wire is grey, when you turn the key on run you get pump power for 2 seconds.
#40 of 49 FUEL PUMP by streetrodder2 Apr 15, 2009 (5:11 pm)
I have a 2001 S10 with the 4.3. Having some problems starting. Checked fuel pressure at the shrader valve under the hood and turned the key on and got 55lbs of pressure momentarily then the pressure dropped to nothing without even trying to start the engine. It says in the manual that there should beat least 55lbs of pressure then drop 3 to 10 lbs below that point when the engine is running. If I hit the starter a couple of quick times while the pressure is up it will start and run flawlessly. Any ideas on why the pressure drops to zero?
#41 of 49 fuel guage doesn't work anymore by d_metivier Apr 19, 2009 (7:11 am)
i have a 2003 gmc sonoma crew cab ZR5 4x4. i was noticing problems with my fuel guage so i changed the fuel pump and sending unit out. well to my surprise it didn't fix the problem. whether the tank is full or empty, the guage reads empty and the fuel light is on 100% of the time. does anyone know a fix for this? Replies to this message: gonogo (Apr 20, 2009 6:56 am) oldiron (Jun 29, 2009 3:27 pm)
#42 of 49 Re: fuel guage doesn't work anymore [d_metivier] by gonogo Apr 20, 2009 (6:56 am)
Replying to: d_metivier (Apr 19, 2009 7:11 am) Don’t know if this will help but best I have. Full is 250 ohm and empty is 40 ohm. 2 wires come from the sender to pcm. 1 is ppl and other is orn/blk, orn/blk is ground. It goes to SP422 on LH frame rail behind cross member at transmission. Seeing you have empty tank I would trace the orn/blk first for loss of ground. Good luck
#43 of 49 Re: fuel guage doesn't work anymore [d_metivier] by oldiron Jun 29, 2009 (3:27 pm)
Replying to: d_metivier (Apr 19, 2009 7:11 am) Exact same problem on my 4 cylinder manual trans. I found a broken orange wire at a connector right along side the transmission. I think a stick or branch on the road may have cut it since the wire is very tiny. I repaired the wire and the fuel gauge works fine now.
#44 of 49 Re: ? [jdinin] by ridetrue Aug 14, 2009 (9:57 am)
Replying to: jdinin (Nov 26, 2008 4:45 pm) Well at this point we have changed the fuel pump, fuel filter, spark plugs, distributor cap, the spark plug wires, and a handful of sensors. Yet the problem remains for it. I have heard the cat might be the problem.
#45 of 49 Re: 2001 S-10 Fuel Gauge [littleosco] by madeupname4 Oct 10, 2009 (1:25 pm)
Replying to: littleosco (Dec 15, 2008 4:22 pm) yo man those sending units are not that expensive and they are very easy to replace. The whole unit including the fuel pump cost about 300 but if you look around online you can find one for about thirty dollars by itself, and I mean the floater of course for thirty dollars.

Messages Page 5 of 6 1 2 3 4 5 6 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums Pickups Chevrolet S-10 & GMC S15 Sonoma Chevy S10 - GMC S15 and Sonoma Fuel Pump and Fuel System