Last post on Feb 06, 2012 at 6:30 PM
You are in the Chevrolet Avalanche
What is this discussion about?
Chevrolet Avalanche, Truck
#8 of 28 Intermediate steering column
Feb 26, 2008 (10:06 am)
I had an 04 Avalanche that needed the intermediate steering column repacked. From what I heard at the time, it was common in this truck. I'm now looking at the new 08 Avalanche. Is this still a problem. I think there was a service bulletin for it, but no corrective remedy(recall) on it.
#9 of 28 popping noise while turning left
Apr 20, 2008 (6:23 pm)
I have an 07 AV LT with 10K miles. Right after buying it, it started making this popping noise after the engine is warm. It only happens while turning and as the car gets warmed up the louder the popping is. You can even feel it under the drivers pedals. Te dealer insists that is the lubrication on the frame mounts but this only helps 1 or 2 days. Any one has had this problem?
#10 of 28 Re: Intermediate steering column [asylum575]
May 02, 2008 (11:06 am)
asylum575, I have a 03 GMC Sierra Denali (by the way Sierra Denali is a ) and they did the same thing with mine! Later they had to replace my steering shaft. Lucky it was covered under warranty.
#11 of 28 Avalanche Popping noise
Aug 09, 2008 (12:09 pm)
My 2005 Avalanche makes a popping noise when I turn to the left or right. The dealer has replaced the steering Column twice and the inter fenders once but the truck still sounds like the wheels may fall off> All tires are good and all lug nuts are fine. Can anyone suggest what I can do to fix> Oh milage is 50,000 nut the noise started at about 20,000
#12 of 28 Love my Truck, but........Has been noisy
Aug 27, 2008 (3:54 pm)
I have an 04 Avalanche, for the past few days when you have your foot on the gas, its okay. But when you take foot off, it sounds like air is going through something. Wife says sounds likes plane taxing into airport, but not that loud. Took it in, tech took it for a ride. Then put it on the rack, said everything looked okay, spun the tires, check to see if anything was loose, nada. Any suggestions.
#13 of 28 valanche transfer case leaking
Sep 03, 2008 (3:11 pm)
I have an 02 Avalanche that had a leaking transfer case. My dealer wanted 1350.00 to replace the case. I went to a local transmission shop and found that at around 80,000 mile THEY ALL WILL LEAK. There is a flaw in the design of the pump inside that allows the pump to slam back and forth till it beats a hole in the case in 4 places. My DEALER knows of NO problem,???, however 4 transmission shops have shown me dozens of cases that have done this and a repair kit is avalible to correct the flaw. Has anyone had this happen??. Mine was repaired WITH the kit for 635.00
#14 of 28 Consistant front end noise problem
Sep 04, 2008 (6:57 pm)
I have had a never ending problem with a vibration in my 04 Avalanche. Today it is in the shop again after having taken it in 6 times within the last 2 years for the same issues. Each time they tell me its normal and give me Bulletin # such as # 1874365 , # 03-08-61-002h and #06-08-61-003a
The following is a list of some of the things they have done to try and reslove the issues as of 01/09/07 Interm Shaft Exercise/Stroke 01/31/07 Crossmember front suspension replace, 03/15/07 Pump assy , power steering - replace, 03/15/07 Hanger and or clamp exhaust system replace, 05/25/07 Lubed balljoints, tierods, pitman, idler arm, service tech still noted hearing issues they showed me bulletin # 03-08-61-002h AGAIN, they then removed the front crossmember and lube and added washers performed road test then found bullentin #06-08-61-003A and then they installed body mounts.
Today the service department checked my truck again and of course was quick to say NOW I am out of warrenty. After long debate and calling Chevy Customer service and opening a case they are going to fix the issues that were long reported BEFORE the warrenty expired. Now they are saying they are replacing the Interm Shaft (instead of just exercising it like the did in Jan 2007) and they are going to re check the suspension.
My advice if you are having issues keep taking it in, Keep getting it noted and if the issue is not resloved to your satification call Chevy Customer Service at 800-222-1020. That way when you are out of warrenty it showes you were trying to get it resloved when it was still in warrenty.
Cross your fingers that this time when I get it back it will be repaired (I HOPE) and no more Bullentins
#15 of 28 Avalanche Drivetrain Rattle
Feb 26, 2009 (2:48 pm)
I have a 2003 Z71 Avalanche with 99,500 miles on it. Just recently, I heard a very metallic rattle coming from below the truck while driving. It was at low frequency at low speeds, and increased in frequency until about 25mph, and then went away. I figured it was a heat shield that broke loose, so I looked underneath and everything seems secure. The noise is not made if the truck is being revved in park...only while driving - I think that rules out the cat/exhaust. It happens in 2WD & 4WD. Any body have a similar issue?
#16 of 28 Re: Avalanche Drivetrain Rattle [krashfreeway]
Feb 27, 2009 (9:46 am)
Why would it rule out the catalytic? My Jeep's catalytic sounds like a can of marbles when driving, but quiet when idling.
Take a rubber mallet to the catalytic. If it rattles, there's your problem.
You may also want to check the various fittings/connections to see if anything is loose. I've had rattles that I was SURE are suspension, but it was just a d-shackle swinging when I applied brakes/gas.
Have you had any maintenance or mods done recently?
#17 of 28 Wheel Bearing?
Mar 16, 2009 (12:42 pm)
I had a similar issue starting at 106K miles. Sound was heard under 25 mph and was intermittantly more pronounces as I made slow-speed turns. I suspected that it might be a front brake part dragging. I had the brakes inspected. Brakes were fine, but not the wheel bearing on the drivers side. That cost $420 to repair including AAA discount. BTW - any brake jobs I suggest replacing with ceramic pads rather than bi-metalic pads. They are worth their weight in new rotors!