Last post on Oct 05, 2013 at 2:53 PM
You are in the Chevrolet Aveo
What is this discussion about?
Chevrolet Aveo, Engine, Hatchback, Sedan
Go to NHTSA to file a safety complaint.
Or call Monday-Friday (8 am to 8 pm ET) (888) 327-4236 TTY: (800)424-9153
#64 of 307 Serious 2009 Chevrolet Aveo Sedan Problem
Jan 03, 2011 (8:09 pm)
My experience with our 2009 Chevrolet AVEO LT Sedan started about 3 months after we purchased it. The car was purchased used and had 36,000 miles on it; so we figured it was a rental or a program car. We purchased an extended warranty (hoping that would help). The first time the problem happened was while driving one day; just before a major intersection. I had to stop at the light. There was a line of traffic in front of me. The first thing that happened was when I let off the brake to edge forward, the car LUNGED forward; so I slammed the brake. When I did the RPM’s started jumping up and down. The car started sputtering; I let off the brake again and it LUNGED again. When the light turned green I pushed on the accelerator and it was as if the engine was not getting any gas. I pushed the peddle to the floor and it finally went. Once it acted normal I continued down the road; only to have it start again. I pulled into a parking lot; and the car became very shaky and the tachometer was bouncing up and down. I pushed on the gas and the engine just cut off.
Since then on a regular basis the car will lose power to the engine; when stepping on the accelerator peddle. The car acts like there is no signals from the accelerator peddle to the throttle assembly. There are days when it does nothing at all. There are times when it happens then the engine will just seem to return to normal, then out of the blue the engine will lose power again. There are never any warnings or check engine lights. None “HAVE EVER” come on. We have taken the car to 3 different Chevrolet dealerships; and to one independent garage; who did have the problem happen once while I was driving with the owner, but the OTC GENISIS Device could not identify what was happening, it just recorded the history of the event. None of the Chevrolet dealers could get it to duplicate or find any codes in the 10 days they had the car. The problem has continued off and on now for almost 6 Months. I have been taking videos with my HTC DROID when the car is having its problem (for all the good that will do). It is like keeping a journal. I show the RPM spikes and drops; the sudden deceleration and the “No response when the gas peddle is pushed. The problem has occurred at all speeds, including when on the freeway. The problem happens at times within the first few minutes of driving; and there are other times it may only happen once or twice in the same day. The car has gone up to two week without the problem happening; then starts again and is even worse for a while. We have already spent over $600 on various (so called fixes); including a complete fuel system cleaning (Including the THROTTLE BODY CLEANING) none have ever helped. I was told By a Chevrolet Dealer it was a bad O2 Sensor (But no check engine light had ever came on). O2 Sensors always cause a check engine light to come on. My wife refuses to drive the car. I think it may be the entire ECU COMPUTER; but no dealer wants to admit that, due to the cost involved.
#65 of 307 Serious 2009 Chevrolet Aveo Sedan Problem
Jan 04, 2011 (6:59 pm)
I was told by the dealer today they will no longer help with our car. No buy back. can't trade it due to negitive equity. 3 weeks ago they said they would do what ever it takes to help; since it was our 3rd vehicle we had purchased from them. They acknowledge the issue, but are under no obligation to help; so they have decided not to. So we will be stuck with a "used Lemon' . and no recourse. Welcome to 2011....
#66 of 307 Re: Serious 2009 Chevrolet Aveo Sedan Problem [dagger77]
Jan 07, 2011 (9:25 am)
I have had a very similar time with my 2009 Aveeo. It's a piece of crap. At 30,000 it needed $600 service. Now the transmission is going. I can't afford this car!! I'm totally upside down on the loan, the thing won't run, Chevy dealer is useless. Today it won't accelerate. I've had check engine light, oil light, HOLD light all on and off, on and blinking etc. What a waste of money this car has been.
#67 of 307 lumpy idling petrol 1.2 DOHC 16valve aveo 2010/2011 model
Jan 18, 2011 (2:42 pm)
#68 of 307 lumpy idling petrol 1.2 DOHC 16valve aveo 2010/2011 model
Jan 18, 2011 (2:42 pm)
hello just took delivery of a brand new Aveo petrol model 1.2 DOHC 16valve 60 miles on the clock and at idling of 500rpm it dont seem to be idling that smoothly at normal engine temperature. If I crank up the revs to 1000rpm the engine to's and fro's from 1000 to 1500rpm on its own. when on 500rpm it stays still there at 500rpm but sort of vibrates rather than idling smoothly. Do you reckon should take it back to dealers, or should I wait until engin has 'run in' a bit more seeing as its new or maybe the ECU is working in 'safe mode' and after amount of time will 'learn' and then it will idle better? - what do you reckon? its not bad but its a bit of a niggle especially on a brand new car like this.
#69 of 307 ODB Code P0303 Misfire Cylinder #3
Feb 23, 2011 (1:54 pm)
#70 of 307 ODB Code P0303 Misfire Cylinder #3
Feb 23, 2011 (1:54 pm)
I have a 2009 Chevy Aveo LS, 4 door sedan with 5 speed manual transmission and 1.6 Ecotec egine. About one week ago I got the infamous flashing yellow engine symbol light and car began to run rough, idle rough, lose lots of power and gas mileage drop 10 mg a gallon immediately.
1) Went to Autozone after checking on this website and researching the internet for others that may have similar problem. Code reader at Autozone gave a P0303 cylinder misfire #3. Thus I bought 4 new spark plugs, Platinum NGK V power to replace the copper tipped NGK from factory. Hoping this might be solution or at least a cheap fix if lucky. After finally figuring out how to take off the black plastic cover to the engine ignition coil pack that had the four spark plugs under it, I changed out the old plugs and put in the new ones.
2) NO LUCK, car did run noticeably better but still flashing yellow engine light and slight rough idle within few miles of driving with new spark plugs. So call dealer and set up appointment to have them run their diagnostic machine check on the Aveo. This will cost you so expect to plunk down at least $75-$100 just for them to hook the machine up to your car but it is worth it.
3) Today I am $307 poorer! Yes, I have over 57250 miles on the car, all highway, so warranty of bumper to bumper was expired and no good. Apparently after doing more research, Aveos seem to all have a problem with their ignition coil or what the dealer calls coil or coil pack or coil bridge which sits on top of the four spark plugs with 4 black rubber boots that look like tits on a cow hanging down, literally. Inside those black rubber boots are the spark plug wires. Basically unlike other cars where you can just change out a bad spark plug wire for $25 or less and take out bad spark plug wire and put in good one, Chevy Aveo does not allow for that, YOU will have to buy the entire new coil pack or ignition coil pack, there is no way to fix just one or replace that bad spark plug wire, thus you have to buy the entire coil!
3) After doing much research and seeing other Aveo owners comment and checking ODB code reports, around 30,000 to 60,000 miles on Aveo there is a high probability that you may have a spark plug wire go bad inside this coil pack causing your check engine light to come on or stay on or flash or blink and it may give you the P0303 code. Thought others on here would like to know this so they do not drive themselves crazy trying to figure it out or spend lot of money on other areas trying to fix this problem that are not necessary.
4) I paid $144 for the labor and diagnostic machine reading plus $152 for new coil pack today. I got off easy I thought considering that I priced a new coil pack at Autozone and Oreillys last week and both were $762 - $815 each! I only found one other place online that had the new one for $426 for the coil pack alone. Granted it is not hard and is easy to install this coil pack, simply disconnect the connection plug on side of it, unscrew 2 Torx size 40 screws, lift up coil pack then put the new coil pack in it's place and done, then re-connect connection plug and put back in screws. Only should take 5-10 minutes at most. Key here is finding that coil pack though under $300, just was not able to do it so I took it to the dealer.
5) WARNING For those of you that think, oh what the hell, I can drive it anyway, so what if I lose a little power and light flashes or it idles rough I will get it worked on later when I get time. DO NOT DO THIS. You will ruin many more other parts or components that tie into your emission system, engine system and exhaust system which will screw up the catalytic converter, O2 sensor, and many other miscellaneous parts. The first two mentioned will run $150 for O2 sensor or more and the catalytic converter will run around $1000 or more to fix plus it could even harm engine valves and heads, not counting the labor also.
So it is not worth it. Go get it fixed immediately or stop driving your Aveo until you can have it fixed.
Had mechanic today tell me that he had worked on 3 other Aveos last year that the owners had ignored this warning light and kept on driving the car for many more thousands of miles until it would not hardly run or start at all, then try to have it fixed and ended up causing serious damage to the Aveo and having a several thousand dollar repair bill. Thus if you get one of these flashing engine yellow lights or the light stays on constantly or you go to Autozone and get a code reading of P0303, I strongly recommend you go to your dealer ASAP and or if you know where to find one of those new coil packs for less than $152 you can do it yourself.
#71 of 307 My experience 2 years later after buying 2009 Chevy Aveo LS
Feb 24, 2011 (10:20 am)
My experience with buying a new 2009 Chevy Aveo has been pretty good.
Only problems I had during first year of ownership the dealer resolved immediately and did a great job with no hassles. Very pleased with the dealer, it is actually too bad Chevy does not include the actual dealer mechanics in their product design or get ideas or suggestions from them first before building or designing a new car, for it is these people that actually know what will work and last and hold up well as opposed to the engineers that come up with some pretty stupid ideas for design thus causing a lot of problems for the car owner and a lot of needless repairs.
Year 1 - I had to have the weather strips along both driver and passenger door adjusted and built up and re-attached so the howling wind or squealing loud wind noise would stop, and dealer fixed this for me during first year.
Second problem I had and it was covered under warranty also was the front left wheel bearing went out, no big deal, just a slight noise which I knew what it was immediately from past experience owning other car brands having same problem, dealer fixed this as well. This is something that happens and is normal wear and tear, I actually think I did it when I hit a hidden pot hole on I44 turnpike in Oklahoma last Feb running about 75 mph, since right after that I noticed the noise coming from front left wheel. Who knows maybe not. Anyway it was under warranty and got it fixed.
Year 2 - No problems at all, drove for entire second year and no problems other than the fact I had to replace the Hankook factory installed tires. After 27,000 miles they were completely wore out and no good, should have at least lasted 40-50 thousand miles, anyway at the end of year 1, I had new Hankook tires put back on the car, that was not good idea and was a big $300 mistake, I do not recommend Hankook to anyone now, they are not good tires to last, or well you do not get your moneys worth out of them at all, they wear out too fast and are far too expensive since they only last one year or year and half. This second set I have are ready to be replaced now and only have a little over a year and one month driving on highway with them after 30,000 miles. And this was with me rotating the tires 4 times in one year, helped a little bit, I may be able to get through spring and summer but doubt much more longer than that.
Year 3 - Check engine light came on and started flashing within couple blocks of home driving in from work last week, car immediately began to run rough, idle rough, misfire and lose power. I took it to Autozone and had it checked for free next day and got the ODB code P0303 when checked for free at Autozone. Changed out spark plugs, improved the rough idle and loss of power and gas mileage but still it was flashing check engine light and running rough or missing and losing power. Took to dealer yesterday, out of warranty now, I have put on 57,684 miles on it in little over two years, all highway driving 55-65 miles hour for work. Anyway, problem was the spark plug wire inside the ignition coil pack that sits on top of the spark plugs, unable to repair the one wire that was bad, have to buy entire coil. Checked prices at parts stores and best I could find was in $400 range for new coil, thus I ended up paying $307 to have new one installed. $152 for parts and $144 for labor of which $75-$100 of the labor is for the diagnostic hook up to machine that can tell Chevy mechanic exactly what is wrong unlike the Autozone hand held code machine reader you can get them to check with for free. Anyway I spent $14 on new spark plugs also at Autozone and even though they were not in bad shape yet I replaced them, according to manual they are to be replaced every 25,000 miles and no more than 37,000 miles, so I guess 57,000 plus out of them was not bad.
Conclusion - for what I paid for this brand new in Jan 2009, $10,675, I really cannot complain, and overall have been very pleased with the car or well more then pleased since it has exceeded my expectations. It is a manual 4 door sedan LS 2009. The gas mileage has been great. 40-46 mpg on highway driving always at 55-65 or more. The lowest gas mileage I ever got was 33.5 mpg and that was driving all in a city one week in stop and go traffic. Never have had a problem with anything tearing up inside the car, no road noise issues, no body part issues, no squeaks or noises, just the things I listed above. If I could have found a ignition coil pack for the car myself for under $300 I would have done this last repair myself but just the way it goes.
For all of those that have had bad experience, I feel for you that is no fun and expensive, but looks like Chevy is putting the AVEO to rest now this year and will not be building anymore, thus not much more time left for griping or complaining about this model of car! Looks like a new model, the Sonic will debut this fall and take AVEO place. Oh well, now to got look for some deal on new tires. It never ends, all any car ever does is cost a person money to operate them, an ongoing expense necessary to work or live in USA, no more no less than another tool. And well all tools wear out or need to be maintained, just a person hopes to buy a car for small amount of money and hope not to spend a fortune repairing it or keeping it running.
Maybe some day they will make a car like that, I have yet to own a car or truck yet that did not have to have something done to it or repaired or replaced or worked on and I have owned many. I just try now to buy or operate the least expensive model to buy and operate/repair that I can if I can. It changes from model and make each year sadly if a car makers gets one right for one year it seems they always change it in the next year or so it goes and one year model is never the same quality. Go figure.
Anyway here is wishing everyone owning AVEO many trouble free miles of driving.
#72 of 307 Re: Serious 2009 Chevrolet Aveo Sedan Problem [hopewell]
Mar 13, 2011 (1:56 pm)
Wow...I am suprised at some of the posts with the Chevy Aveo. Mine just turned a little over 106,000 miles and this car has paid for itself. My check engine light is on...the code is reading the second 02 sensor. I've never had any major repairs with it. Just its normal wear and tear and up keep at this milage. (battery, new belts, breaks, rotor rotation, tires, spark plugs, wires, and a couple worn hoses...Now looks like just an O2 sensor needs to be replaced) I had the issue once with the flashing engine and hold light. It was spark plugs. I hope that helps. I am going to continue making the little repairs to my aveo. I plan on giving the car to my mother who drives very little to start with. I want to make sure it is in good shape and will be safe for her. Im thinking about purchasing the Chevy Sonic once it hits the market.
#73 of 307 Engine Wont Start Aveo Help!
Apr 04, 2011 (12:06 am)