You are here: Forums SUVs Isuzu Trooper Trooper fuel pump fuse shorting out

Trooper fuel pump fuse shorting out

7 messages,  Last post on Apr 10, 2009 at 5:15 AM

You are in the Isuzu Trooper Forum. Your Hosts are steve_ & tidester

What is this discussion about? Isuzu Trooper, Electrical, Fuel System, SUV

Messages Page 2 of 2 1 2 Prev Next Last

Go To Msg # Search This Discussion

#3 of 7 '91 4-cyl cranks by no fire by troopermom May 10, 2007 (7:03 pm)
We've got a '91 trooper, my son drove it home on Sat and it would turn over but not fire on Sun. We've looked at fuses, spark plugs and now are thinking relay (?) Do both relays die at the same time? We've changed the fuel pump (pain in the behind)and it's been running ok. Anybody have other ideas to check along with relays? Thanks Replies to this message: atfdmike (May 11, 2007 3:35 am)
#4 of 7 Re: '91 4-cyl cranks by no fire [troopermom] by atfdmike May 11, 2007 (3:35 am)
Replying to: troopermom (May 10, 2007 7:03 pm) Hi, not personally familiar with ignition, but if starter cranks and fuel is present then try checking igniter in dist.   Disconnect high tension cable between coil and distributor. Hold coil high tension cable end approximately .23 inch (1/4 inch) from suitable ground. Engage starter and check to see if spark jumps across gap. If spark is not present, check for defective ignition coil. If ignition coil is satisfactory, I would check power transistor, which is a little more involved. The power transistor, in-line between the ignition coil and ECM, is the switch that triggers the coil. By calculating various inputs, the ECM controls ignition timing through its control of the power transistor. The ECM considers input from the crank angle sensor, throttle valve switch, coolant temperature sensor, air flow sensor and vehicle speed sensor when calculating ignition timing. I would check for loose or corroded connectors on these items as well.
#5 of 7 Re: Trooper fuel pump fuse shorting out [dwarnock] by thomas30 May 14, 2007 (4:22 pm)
Replying to: dwarnock (May 03, 2007 7:20 pm) Did you ever find the problem, I have the same one. Please e-mail me if you did thomas_d_millsyahoo.com Thanks Thomas
#6 of 7 Re: Trooper fuel pump fuse shorting out [dwarnock] by jdwenger May 20, 2007 (5:34 am)
Replying to: dwarnock (May 03, 2007 7:20 pm) Hi, I had the same problem and figured out that the problem is with the sending unit the rubber insulation where the leads go through the plate wears out and it shorts out causing the fuse to blow. the reason that the truck will still start sputter and die out is because there are two seperate fule pump fuses one for exelerating and one for idiling or something
#7 of 7 Fuel Pump by grabber7 Apr 10, 2009 (5:15 am)
How do you change out the fuel pump in a 2002 Trooper?

Messages Page 2 of 2 1 2 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums SUVs Isuzu Trooper Trooper fuel pump fuse shorting out