You are here: Forums Vans & Minivans Nissan Quest Nissan Quest/Mercury Villager Gas Smell in Cabin

Nissan Quest/Mercury Villager Gas Smell in Cabin

6 messages,  Last post on Jul 07, 2009 at 4:00 PM

You are in the Nissan Quest Forum. Your Host is Karens

What is this discussion about? Nissan Quest, Van

Messages Page 1 of 1 All Messages Displayed

Go To Msg # Search This Discussion

#1 of 6 Gas smell in cabin of 1995 Nissan Quest when cold by noodle2 Feb 24, 2007 (2:45 pm)
I had experienced a strong gas smell entering the cabin of my 1995 Quest usually when cold and running the heater or defroster. The smell would eventually disappear once the engine had warmed up. I came here and read several posts suggesting replacing the fuel rail rubber hoses or tightening up the screws on the clamps. The gas vapour leaks out of these ends when cold and if not snug. I inspected the hoses and they looked fine and I tightened the clamps' screws (all were somewhat loose). And yes, they were hard to get to! I THOUGHT I had tightened all the clamps but the gas smell continued as before. Finally after a few weeks of this driving me crazy, I took another look under the hood and realized there was one more hidden clamp which I missed and it was quite loose. I tightened that up and the gas smell is now gone!   Here's a photo showing the screw locations. Sorry I couldn't get a better shot. As I said, it was tough to get in there with a screwdriver. Hope this is helpful to you.   Replies to this message: steven38 (Dec 16, 2008 1:41 am) jayberg (Dec 16, 2008 6:12 pm) jayberg (Dec 16, 2008 7:14 pm) ESwan1 (Jan 16, 2009 11:58 am)
#2 of 6 Re: Gas smell in cabin of 1995 Nissan Quest when cold [noodle2] by steven38 Dec 16, 2008 (1:41 am)
Replying to: noodle2 (Feb 24, 2007 2:45 pm) We recently experienced the same problem you did on our Mercury Villager when we had unusually cold weather. Due to researching the manual, I was getting ready to replace the purge control solenoid when I found your posting. I tightened the clamp screws as you recommended and THE PROBLEM IS FIXED!!! You saved me both money and frustration with your posting. Many, many thanks!!! Replies to this message: jayberg (Dec 16, 2008 6:12 pm) jayberg (Dec 16, 2008 7:14 pm)
#3 of 6 Re: Gas smell in cabin of 1995 Nissan Quest when cold [steven38] by jayberg Dec 16, 2008 (6:12 pm)
Replying to: steven38 (Dec 16, 2008 1:41 am) We have the same problem with our 1996 Quest, And now that winter is here the gas smell is terrible!!! I had tightened all the clamps a while back but I also missed that one that you pointed out in the picture.. I am going to tighten that one and see if it works I'll let you know what happens... Thank You so Much!! Replies to this message: jayberg (Dec 16, 2008 7:14 pm)
#4 of 6 Re: Gas smell in cabin of 1995 Nissan Quest when cold [jayberg] by jayberg Dec 16, 2008 (7:14 pm)
Replying to: jayberg (Dec 16, 2008 6:12 pm) Found the problem I have a pinhole leak on the gas line that runs under the throttle body... I now have all the clamps tightened now i just have to change a short piece of hose and then all will be fine.. Thanks again edmunds rules!!
#5 of 6 Re: Gas smell in cabin of 1995 Nissan Quest when cold [noodle2] by ESwan1 Jan 16, 2009 (11:58 am)
Replying to: noodle2 (Feb 24, 2007 2:45 pm) Thanks for this post! Some of the screws were so hard to get to, I had to buy special long pliers to reach and turn them. If you keep following the hose from the fuel filter(the metal canister) to the engine, there are even more screws to tighten...(They would be located to the left of the picture) that is where I found my leak.
#6 of 6 96 villager with gas odour in cabin by yahushua Jul 07, 2009 (4:00 pm)
changed the fuel tank, changed the fuel filter, changed the carbon filter, tightenened every connection, changed vacumn hoses, checked the filler pipe, ran flex lines and bypased metal lines just to be sure it wasn't a pinhole leak. checked every internet site.   Finally listened to my wife and changed the gas cap...That was it ...10 bucks!   No diagnostic light... nothing!...but all along it was the fuel cap!   One month of trying this and that and pulling what hair I had left out!

Messages Page 1 of 1 All Messages Displayed

Go To Msg # Search This Discussion

You are here: Forums Vans & Minivans Nissan Quest Nissan Quest/Mercury Villager Gas Smell in Cabin