You are here: Forums SUVs Ford Expedition Ford Expedition Transmission Problems

Ford Expedition Transmission Problems

132 messages,  Last post on Nov 21, 2009 at 3:08 PM

You are in the Ford Expedition Forum. Your Hosts are steve_ & tidester

What is this discussion about? Ford Expedition, Transmission, SUV

Messages Page 14 of 14 1 ... 8 9 10 11 12 13 14 Prev Next Last

Go To Msg # Search This Discussion

#128 of 132 Re: 08 Expedition-"Scraping" noise [roger341] by buzzz1 Oct 07, 2009 (7:40 am)
Replying to: roger341 (Oct 07, 2009 4:59 am) Figure out how to make it 'scrape' consistently. Then take the service rep on a test drive. It's not normal. There is a TSB for a sqawk noise on hard accleration at around 30mph, but it sounds like a belt slipping, not scrapping. Could be related though. Here is the info for that. TSB 09-6-1   04/06/09 6R75 TRANSMISSION - SQUAWK NOISE DURING POWER/FORCED DOWNSHIFT   FORD: 2007-2008 Expedition   This article supersedes TSB 08-19-8 to update the vehicle model years and remove the production fix date. ISSUE Some 2007-2008 Expedition vehicles equipped with a 6R75 transmission may exhibit a squawk type noise during hard acceleration down shifts (4-3), (5-3) and (6-3) downshifts. The noise is produced during the release of the overdrive clutch.   ACTION Follow the Service Procedure steps to correct the condition.   SERVICE PROCEDURE   Follow Workshop Manual (WSM), Section 307-01B to replace the overdrive friction plates. WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage IMPORTANT : Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
#129 of 132 stuck in 4x4 by highside Oct 14, 2009 (5:18 pm)
after using my 4x4 in reverse I switched it over to 2wd but it will not go back to 2wd instead it is still in 4wd, it is driveable but when you release the gas pedal the rpms go to idle no matter how fast you are traveling, help thanks
#130 of 132 stuck in 4wd by alwaysfords2 Oct 15, 2009 (4:42 am)
Actually it may not be driveable. If it is stuck in 4WD and you make tight corners on dry pavement you are risking damage to the drive line. Sounds to me like the transfer case shift motor didn't move out of 4WD.
#131 of 132 Re: Expedition Transmission clunking [dieselone] by spud1w Nov 13, 2009 (1:28 pm)
Replying to: dieselone (Jan 13, 2009 7:32 pm) I'm having a delayed shift from 1st to 2nd (Slips into neutral) on my 03 Expedition 5.4L 4x4. Just took it to my repair shop today and nothing shows on the codes and obviously it won't act up for mechanic. (Intermittent issue). He mentioned it may have to be reflashed at a Ford Dealership. How much did your reflash cost?   Thank you,   Spud1W
#132 of 132 03 Expedition delayed shift, Reflash needed? by spud1w Nov 21, 2009 (3:08 pm)
I'm having a delayed shift from 1st to 2nd (Slips into neutral) on my 03 Expedition 5.4L 4x4. Just took it to my repair shop today and nothing shows on the codes and obviously it won't act up for mechanic. (Intermittent issue). He mentioned it may have to be reflashed at a Ford Dealership. How much does a reflash cost?    Thank you,    Spud1W

Messages Page 14 of 14 1 ... 8 9 10 11 12 13 14 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums SUVs Ford Expedition Ford Expedition Transmission Problems