Last post on Jan 22, 2010 at 9:00 AM
You are in the Volvo S60
What is this discussion about?
Volvo S60, Volvo S60 R, Sedan
#5 of 14 S60 Clunking Noise
Nov 06, 2007 (6:39 pm)
I have a 2002 S60 with a clunking noise when I go over
bumps. SOunds like sometning is loose. Is their a bushing that is a common failure on these, or is it more likely a strut? ANy help is appreciated. I hate going to the dealer.
#6 of 14 Re: S60 Clunking Noise [tim15]
Nov 13, 2007 (10:18 am)
this may seem silly, but check the spare tire.
#7 of 14 Starting issues
Jun 24, 2009 (12:12 pm)
My 2007 S-60 2.5T still under warrantee does not like to start 1st try every morning and after sitting all day at work. Tries to start cought and spoutters and dies. starts immediately on 2nd try. Volvo changed the ignition switch almost a year ago helped until about a month ago. This week the computer shown no error codes they tested the electrical system told me it was ready. This AM same as always. Sounds more like a fuel problem to me.
#8 of 14 Re: S60 Clunking Noise [tim15]
Jul 02, 2009 (3:14 pm)
don't let this go - I had this problem with my 2001 and waited quite a few miles before insisting on it being checked. Have had to replace bushings on front and rear.
#9 of 14 s60 starting problem
Aug 09, 2009 (10:22 am)
I went to start my s60 and the key turns but not all the way so the car won't turn over. Any suggestions?
#10 of 14 Re: Strange Noise Coming from Engine on Cold Starts [jozso]
Aug 25, 2009 (12:56 pm)
Did you ever figure out what was wrong and was the problem ever fixed. I am having a very similar problem with my S60. It has been at the dealer for a month and virtually everything has been replaced on the vehicle and it still isn't fixed. I'm not sure what to do next.
#11 of 14 Re: S60 Clunking Noise [pgallins]
Sep 21, 2009 (8:38 pm)
Yes Yes Yes
It appears they finally got it to start. Hoy Fox Volvo El Paso tells me Volvo told them to change the injectors. I think it worked. Starts 1st try every morning so far been 1 week.
Took her for a test drive El Paso to Dallas and back. spent the night started fine and still got 29.8 MPG for the entire trip.
#12 of 14 Re: S60 Clunking Noise [cas1]
Sep 23, 2009 (7:10 am)
New to this forum but this sounds like exactly what is going on with my 2006 S60 T5. My wife will drive it to work in the morning and then like clockwork at lunch it will sputter and not start and the second time it will start up.
I have been into our Volvo dealership going on 8 times (UGH!!!) and they have replaced the computer, putting in a new fuel siphon this time and replaced the antenna rings. I am going to call them right now to see if they have looked at the injectors (good call).
Here is a video of our issue.
#13 of 14 Re: S60 Clunking Noise [thomas83178]
Sep 23, 2009 (6:17 pm)
This was the 3rd or 4th visit. the service adviser told me Volvo told them to change the injectors. They had the car for 1 week. It happen the first time when it had 1000 miles and they change the ignition switch, that seemed to work for about 8 months.
#14 of 14 Re: s60 starting problem [mollyb1]
Jan 22, 2010 (9:00 am)
I have a 2003 s60 for two weeks. Twice, It could not start. Plenty of power to accessories unitl I turned the key to start, Then all accessories/lights turned off. No starter sound. First, time, I had it towed to the shop. When they took it off the wrecker, the car started. Yesterday, after about 20 minute of Off/On key switching, the car started. Is this similar to your problem? And, have you been able to get your problem identified or repaired. The Web reports many similar problems lasting from minutes to weeks.