You are here: Forums Vans & Minivans Chrysler Town & Country/Dodge Grand Caravan Dodge Grand Caravan Steering

Dodge Grand Caravan Steering

171 messages,  Last post on Nov 21, 2009 at 6:09 PM

You are in the Chrysler Town & Country/Dodge Grand Caravan Forum. Your Host is Karens

What is this discussion about? Dodge Grand Caravan, Chrysler Town and Country, Plymouth Voyager, Steering, Van

Messages Page 17 of 18 1 ... 12 13 14 15 16 17 18 Prev Next Last

Go To Msg # Search This Discussion

#160 of 171 Re: 2006 grand caravan [akindy] by dodgeman7 Oct 26, 2009 (10:30 am)
Replying to: akindy (Oct 26, 2009 9:39 am) If the noise is coming from the engine, then it's not the rack and pinion or steering, it's in the engine block. It does seem to be a steering problem though and the noise may be coming from the steering pump and not the engine due to the humming noise.   Replace the power steering reservoir first before replacing the rack and see if that fixes your problem, if not have another mechanic check it out and see if it's something else.
#161 of 171 Re: Power Steering Problem - DGC 2003 [ironcity1] by dodgeman7 Oct 26, 2009 (10:41 am)
Replying to: ironcity1 (Sep 03, 2009 2:26 pm) Hi Bill,   Sorry been away from this site for a while. I found this website on the error code P1494 and I'm guessing it has to do with the gas cap being loose. Tighten it up and drive it around for a few days until the computer resets it's self or you can clear the codes by disconnecting the negative battery cable for 30 seconds to reset it's self.   Check out this site for more information: http://forum.chryslerminivan.net/showthread.php?t=3244
#162 of 171 Re: Back hoe help [tomg4] by dodgeman7 Oct 26, 2009 (10:55 am)
Replying to: tomg4 (Sep 26, 2009 4:54 pm) I know, that larger hose is a real pain. Mine looked like it was fused together and looked melted on the reservoir, but after a screwdriver and a trusty air hose, it came off. I did not want to try the WD-40 trick due to the steering fluid and rubber hose not co-operating with each other and breaking down over time, so I stuck with my air compressor.   My hose does not look that great at the reservoir and I wanted to change it when I did my power steering reservoir, but looked to be too much work so I passed and lucky for me it still does not leak.   I have to try that beer thing though next time.
#163 of 171 Re: 2006 grand caravan [akindy] by srs_49 Oct 26, 2009 (11:28 am)
Replying to: akindy (Oct 26, 2009 9:39 am) Are you sure it's coming from the engine and not the front tires? Maybe your CV joints?   Does the noise change depending on whether you are accelerating, maintaining a steady speed, or decelerating?   Does the noise change when making a turn?
#164 of 171 Re: 2006 grand caravan [xwesx] by sbradshaw Oct 27, 2009 (4:03 pm)
Replying to: xwesx (Oct 23, 2009 8:42 am) I can honestly say the '01 Caravan has been a good one except for this. As for crazy... for taking it back to the mechanic that swapped the steering pump out twice before giving up and the 2nd mechanic shop for diagnosing the rack and pinion only for the noise to return a few weeks later. He said it was defective too and wanted to swap out again. Before I did that I started looking for answers myself. The reservoir replacement or cleaning was a inexpensive trial process. Now tell me what could be causing the faint popping in the rt front wheel after hitting a pothole. Changed tire & rim (warped it). Still pops from just turning the wheel even when the vans not moving and no visible boot damage so not pay'n for a cv joint just yet. It's AWD. Any suggestions? It driving me CRAZY not knowing. but don't want ot get taken for a ride again. Replies to this message: srs_49 (Oct 28, 2009 2:27 am) xwesx (Oct 28, 2009 8:54 am)
#165 of 171 Re: 2006 grand caravan [sbradshaw] by srs_49 Oct 28, 2009 (2:27 am)
Replying to: sbradshaw (Oct 27, 2009 4:03 pm) Ball joint or tie rod end??? Replies to this message: xwesx (Oct 28, 2009 8:54 am)
#166 of 171 Re: 2006 grand caravan [srs_49] by xwesx Oct 28, 2009 (8:54 am)
Replying to: srs_49 (Oct 28, 2009 2:27 am) That is my thought as well. I was getting occasional "popping" sounds coming from the front end of my '98 DGC, usually over rough roads. No such sounds after replacing the ball joints. I also replaced the front struts at the same time, but I cannot figure how the strut could create such a sounds under the conditions sbradshaw described. The ball joints on mine were toast.
#167 of 171 Re: Steering wheel problems [sunnyb] by chuck789 Nov 09, 2009 (7:17 pm)
Replying to: sunnyb (Oct 18, 2007 6:41 pm) I have the same issue with my 2007 Chrysler T&C. the dealer ship has replaced the power steering resivor and filter as mentioned by others in the forum. but the issue still persist. if you find an answer please let me know. You are not alone. it is very dangerous and annoying. No solution yet? help
#168 of 171 power steering issues by chuck789 Nov 09, 2009 (7:36 pm)
I have a 2007 Chrysler Town and Country, similar to most of the post I have steering whine. the dealer replaced the power steering reservoir and filter, but the problem is still there. the steering also seizes/stops while driving. it will kick back in, but is dangerous during turns. I took it back and the dealer says they cant find anything. I need help soon before we crash and someone gets hurt! please respond if you have any help.   #22 in the forum has the same problems also. Please help.
#169 of 171 steering whine by reticulum Nov 11, 2009 (7:10 pm)
I've had a steering whine on my 2004 town and country for more than 4 years. The wheels had no problem to turn but the sounds was becoming horrible. I bought a used power steering pump thinking the problem was coming from the pump. While I was getting ready to change the pump I saw all thoses post about the reservoir and I decided to give it a shot. I have changed the reservoir an the whining is gone. It is like driving a new car When I looked at the filter....it was not clogged but many debris were on it.

Messages Page 17 of 18 1 ... 12 13 14 15 16 17 18 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums Vans & Minivans Chrysler Town & Country/Dodge Grand Caravan Dodge Grand Caravan Steering