Last post on Nov 07, 2013 at 7:40 AM
You are in the Dodge Sprinter
What is this discussion about?
Dodge Sprinter, Dodge Sprinter Cargo, Van
#84 of 95 To all having problems with stalling sprinters
Aug 16, 2011 (5:29 pm)
This happened to me in N.Carolina and I managed to get it back to Michigan, and immediately my boss put our 2005 dodge in the local sprinter shop . Pete , our very expierienced mechanic picked up an engine wiring harness that he had taken out of another 2006 and showed me where the wires and the wire loom had melted, and said with surety upon listening to me as to what it was doing, that we probably needed a new engine wire harness that controls everything in the engine area. Well needless to say 4 hours later and $450.00 , and a melted wiring harness on the floor , My bosses beloved toy that he bought new was running without fail,and has been since
So the problem, with 75% surety, is to get your sprinter to a certified sprinter shop and have them check the engine wiring harness
#85 of 95 Sprinter quit running while being driven & 1 click no starting
Mar 11, 2012 (6:04 pm)
Sprinter quitting when driver. Ck your power windows at same time if it stops to due to no power . Your try to start and you get- Note ( 1 click on a relay > motor Relay or starter Relay)< The ground to Motor is Bad a Open in the grounding. ( Check by placing hand on ground post see if HOT!!!! ) Oem has 2 cables grounds. 1 from battery to frame other frame to motor. To fix this is easy run a new ground cable from motor mount bolt back to the ground on the battery. You can test by jumper cable motor to Ground Post TOO. It will turn over but slow.
#86 of 95 07 Sprinter in limp mode (emergency)
Jan 15, 2013 (2:24 pm)
Here is my problem...have an 97 Sprinter, converted to a mobile grooming Van..around 30K miles with lots of ideling of the van. No I do have the engine go into emergency mode...can get it out of the emergency mode by restarting.
Mercedes Dealer tells me I should replace everything, starting the turbo and the EGR, another certified sprinter serice dealer tells, the main computer needs to be replaced (2300$)...not sure what to do now...any advise. Van has been serviced every 6 months and is in very good shape otherwise
#87 of 95 Re: 07 Sprinter in limp mode (emergency) [tampel]
Jan 15, 2013 (2:26 pm)
07 sprinter, not 97
#88 of 95 Re: To All Sprinter Owners.......To Be Cont'D............ [los5961]
Sep 08, 2013 (7:17 am)
Hi All it's Funny i Have All of Those Problems and yes i will Be with you All For the Lawsuit , including the Dash ac Control i Changed 2 and need another one , and changed Transmission That Cost $7500 on 220,000mi Now My Motor Cutting Off ,Some Kind of Electric Problems ? and Changed the Harmanik Ballancer 95000mi , and 2 AC Compressors and 4 ac Lines,and All Turbo Rubber Houses 2 Times Have to By Pass the Ac Fan To Keep it Cool it Look Likes All Wiring All Messed up , Thanks For All of the Postings and Lets Find Solutions ?
#89 of 95 Looking For Hope
Sep 08, 2013 (7:20 am)
#90 of 95 Re: Gas Sprinter Crank But No Start (Intermittent) Problem [tintent]
Sep 08, 2013 (5:07 pm)
I had a similar problem found the crank sensor and the cam sensor would get hot and stop working. 10 minutes later it would start and run fine. Just don't turn it off.
#91 of 95 Re: Ignition/Starting problems [rdean1]
Sep 09, 2013 (12:46 pm)
i Have the Same Problems , Now My Van in the Dealer, They Said Needs ignition Switch and Fuse Block and my Bill Going to Be around $700 Will see if That Fix it Tomorrow ?
#92 of 95 Re: Hot restart problem [fiteqprpr]
Sep 09, 2013 (12:53 pm)
Hi any more Problems ?
#93 of 95 Re: Sprinter starting problems [ladydi007]
Sep 09, 2013 (12:57 pm)
i Have Same Problems , Did you Fix it ?