Last post on Oct 26, 2013 at 6:14 AM
You are in the Ford Explorer
What is this discussion about?
Ford Explorer, Heating / Cooling, SUV
#515 of 536 Re: 2008 EB Ford Explorer heat/air clicking and no heat [parkerj4]
Feb 04, 2013 (5:40 pm)
I had almost exactly the same issue come up. Not the check engine light so I doubt that I have a gas cap leak issue, but the climate control system was clicking if not in the right spot, followed by total failure. I saw your follow-up post about the gas cap valve leak. I'm confused how that would have contributed to heater system failure. That sounds like a separate issue. What was the final outcome / repair for the climate control system? Thanks in advance.
#517 of 536 2005 Ford Explorer (Clicking Problems)
Mar 25, 2013 (4:55 pm)
I have a 2005 Ford Explorer that clicks whenever I turn the a/c or heat on. The click comes from underneath the dashboard and I believe it's a climate control actuator problem. I was wondering if that is indeed the case and how much it would cost to correct the malfunction. Additionally, just recently, the heat stopped working.
Any solutions, or ideas? Thanks.
#518 of 536 2002 Ford Explorer
Mar 27, 2013 (10:28 am)
I have a 2002 Ford Explorer. When I try to turn my heat on it makes a loud thumping noise and only cold air would blow. I had a "friend" look at it and he was able to reach in through the glove compartment and move the stick to heat. The heat worked perfectly fine and was hot however once the truck was turned off and then back on the stick was stuck again and I only got cold air. I took it to a mechanic who just told me that he was able to move the stick back to hot but the heater core was shot and needed to be replaced and that until it was replaced I can either have air conditioner or hot air but not both and cannot switch back and forth. He said it would cost $1,000 to fix the heater core. I obviously don't know much about cars but it seems that if the heater core was shot I would not get hot air when I turned it to hot. Does this make sense to anyone and do you think the mechanic is correct. I feel like I am being taken advantage of. Please help.
#519 of 536 Re: 2002 Ford Explorer [lolab1011]
Mar 27, 2013 (11:18 am)
">Hello, We also have a 2002 Ford Explorer. We had the same problem and our problem was not the heater core. It was actually the blend door gear, and alot cheaper than the heater core (about 35 bucks), and its easy to check. If you take off the panels underneath the steering wheel and the center console and its a little bit of a tight squeeze but lay on your back on floor board and look up towards the radio (on your back it would be the left side) and stick your hand up there and feel for a box, you will see it, its probably white. The blend door is hooked to the box and if you pull it out (the box) (you will have to unhook wires and you can open the box, look at it and tell if the gears are striped, (which is what our problem was) go to auto zone or online, and order a new box (30 some dollars) replace it and voila! your truck will work and as a quick fix you can pull the rod hooked to gear out of the box, and put it back into the slot (hooked to the blend door) and leave the panels off your truck and each time you turn the car on, reach under there and flip the gear manually. Super easy! once you get part just replace it all and your good!
If you google 2002 ford explorer blend door gears, you will see the box im talking about, and you will be able to tell which part you can "temporarily" take apart and stick back into the truck to have a quick fix if they have to order the part.
#520 of 536 Re: 2005 Ford Explorer (Clicking Problems) [tpspecialk]
Mar 28, 2013 (3:22 pm)
The diagnosis sounds correct. The cost may vary though. Depends upon which door is sticking, and where it is. I would say $450 to $1000 is the range.
#521 of 536 Air going warm then cold in 98 Explorer, more often when High Temp outside
Jun 14, 2013 (11:24 am)
98 Explorer , you can start it, turn air on and it is cold, drive a bit and as car heats up or if it is really hot outside, will start to blow warm (not hot) air (like freon is low). Then after a bit it will begin to blow cold again. For the last year we have not had to change the Temperature selection knob to get heat, just change the air/heat selection knob. So, Blend Door or Cycle Switch? Also, rear air fan makes awful noise if on, how hard are these to change out?
#522 of 536 Re: Air going warm then cold in 98 Explorer, more often when High Temp outside [lockedhearts]
Jun 17, 2013 (1:03 pm)
OR, (and likely), a bad expansion valve. Not a difficult fix - does require an evacuation, obviously. The part is about the size of a nickel and doesn't cost a lot more than that. Certainly not a big job, other than the evac and re-charge. Usually you need an equipped tech for that.
#523 of 536 Re: Air going warm then cold in 98 Explorer, more often when High Temp outside [nvbanker]
Jun 22, 2013 (9:54 am)
Thanks, will check out the part, get it and see about getting my mechanic to fix it. He is good to me when it comes to labor, so hopefully will be an easy fix.
#524 of 536 Re: 2005 Ford Explorer (Clicking Problems) [tpspecialk]
Jul 02, 2013 (5:16 am)
So would the climate control actuator and "blend door actuator" be the same thing? My 2008 is having the exact same issue.