You are here: Forums Hybrid Vehicles Honda Civic GX (natural gas) Honda Civic GX Fueling Problems

Honda Civic GX Fueling Problems

44 messages,  Last post on Sep 24, 2009 at 6:29 AM

You are in the Honda Civic GX (natural gas) Forum. Your Host is pf_flyer

What is this discussion about? Honda Civic, Fuel System, Alternative Fuels, Hybrid Cars, Hatchback

Messages Page 5 of 5 1 2 3 4 5 Prev Next Last

Go To Msg # Search This Discussion

#38 of 44 Re: gas gauge reads empty [paulslc] by freedml Apr 08, 2009 (6:33 am)
Pull the HPR and send it to a good regulator repair shop. They should be able to either find a diaphragm for it or make one.
#39 of 44 Gas Tank Hanger Bolt by tlclimo1 Jun 01, 2009 (11:39 am)
On my 98 Contour, there are two metal hangers for the tank that clip in the rear and have a bolt holding each of the two from from the front. I do not want to take the other side out for fear it'll lose a possible free nut under a rear seat. My luck. What size are these bolts? They look like they may be metal screws. Tried two sizes from the local hardware store. One too large and other too small. Anyone know exact bolt size for these hangers? Replies to this message: pf_flyer (Jun 01, 2009 11:51 am)
#40 of 44 Re: Gas Tank Hanger Bolt [tlclimo1] by pf_flyer HOST Jun 01, 2009 (11:51 am)
Replying to: tlclimo1 (Jun 01, 2009 11:39 am) Since we don't have a lot of Contour discussions, your best bet would be to post in the Got a Quick, Technical Question? discussion. The folks who hang out there should be able to help you with the info you need.
#41 of 44 Re: Solenoid the problem? [mattod] by danaman Jul 31, 2009 (8:50 am)
Replying to: mattod (Aug 27, 2006 4:14 pm) Hey Matt. I have the same problem with my Civic GX and I want to have it taken to the dealership, but don't know if they will replace the tank like yours did. Please let me know any of the contact info. you have on the dealership that replaced the tank so I can contact them.   Thanks
#42 of 44 Possible safety issue by danaman Sep 23, 2009 (8:50 am)
Recently my 1999 Civic GX would not start at a filling station after a fill-up. My family was stranded and had to have the car towed. We took it to the dealership only to find out that the part (an internal solenoid in the tank) was shorting out. I feel pretty weary about a short in my natural gas tank. Honda has said they don't feel it important to investigate but I know at least 2 others have had the same issue. Not only is it a possible safety issue but a $7000 repair bill. The part is unserviceable and the dealership said there was no preventative maintenance to prevent it. Please respond if you have similar problems with your CNG Honda so we can make sure that this problem can be taken care of.
#43 of 44 '99 GX solenoid by freedml Sep 23, 2009 (2:10 pm)
Solenoids go bad. They open and close whenever you turn the key on, so after 10 years that happens. It isn't a safety issue -- the part of the solenoid with electricity is far away from the gas. Even if there were a spark in the tank, 100% Methane can't explode as there is no Oxygen. So, not a safety issue.   Now, to the repair. Honda has a policy of not reinstalling a CNG tank even if they were just going to remove it to replace a solenoid. But, if you find a CNG-knowledgeable machanic, he can probably pull the tank, change the solenoid and put it back in for a few hundred bucks. Replies to this message: danaman (Sep 24, 2009 6:29 am)
#44 of 44 Re: '99 GX solenoid [freedml] by danaman Sep 24, 2009 (6:29 am)
Replying to: freedml (Sep 23, 2009 2:10 pm) Does anyone know why Honda has a part that fails that they will not replace? I will look into other possibilities to get the car functional again.

Messages Page 5 of 5 1 2 3 4 5 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums Hybrid Vehicles Honda Civic GX (natural gas) Honda Civic GX Fueling Problems