You are here: Forums Vans & Minivans Ford Aerostar Ford Aerostar: Electrical Issues

Ford Aerostar: Electrical Issues

37 messages,  Last post on Dec 14, 2008 at 1:39 AM

You are in the Ford Aerostar Forum. Your Host is Karens

What is this discussion about? Ford Aerostar, Van

Messages Page 4 of 4 1 2 3 4 Prev Next Last

Go To Msg # Search This Discussion

#28 of 37 Re: Turn signals, blower, defogger not working by jfromm Feb 29, 2008 (9:26 am)
Replying to: daniel1956 (Jun 24, 2007 2:17 pm) Hi all,   After weeks of winter having the heater's blower working most of the time, but not when we really wanted it, I tried pulling the multi-switch on the top/left side of the steering column, as was suggested in another post. The poster said this multi switch could be taken apart once removed, and the contacts within it cleaned. I got the switch off, but did not have the smaller star bit required to open the switch, so I just shot it full of WD-40 and tapped and wiggled the switches on it and reinstalled it.   Since then (4 days) we've not had a single failure of the heater/turn signals/defogger that had been a regular occurance. I'd say it was definitely that multi switch. Our local parts store has the switch for about $75. I think I'll leave ours in place to see if it really goes out, then spend the $75 for a new one. Replies to this message: jimmj43 (Mar 26, 2008 2:41 pm)
#29 of 37 ?? Location of [electric] door lock relay ?? by jimmj43 Mar 26, 2008 (2:35 pm)
'92 Aerostar XLT: Both front door switches will activate the 'unlock' function, but neither will activate the 'lock' function. Since I had to repair an electric window problem, I decided to tackle the annoying door lock issue. I sliced some insulation off the Pink/O & Pink/B wires and introduced a cheater battery to test the operation of the solenoid. (For some reason my Haynes manual identifies that solenoid as a 'motor' ?!?!). It behaved just as it should have as I switched polarity back and forth.   I note in the Haynes wiring diagram for the door lock circuit that a "lock relay" (as well as an "unlock" relay) lies in the circuit between the incoming 'hot' and the switch. BTW, the switch tests good. I want to check that 'lock' relay, but I'd rather not have to pull out the entire dash to track it down. Not surprisingly, the little owners manual that came with the van was no help. WHERE should I look for that relay, and how can I positively identify it? Oh. And while you're at it, could you wash my car? Replies to this message: firealarmguy (Apr 27, 2008 4:19 pm)
#30 of 37 Re: Turn signals, blower, defogger not working [jfromm] by jimmj43 Mar 26, 2008 (2:41 pm)
Replying to: jfromm (Feb 29, 2008 9:26 am) You can save a buncha $$ by purchasing a small set of Torx drivers. Some years back I got a set of 5: T30, T25, T20, T15, T10 for ~ $10-15. Money well spent.
#31 of 37 erratic starts by grummpy Apr 11, 2008 (2:27 pm)
my mother inlaw tries to start the van and sometimes it just cranks andsomtimes it starts its not somthing the local mech. apparently can find. they live in mcallen tx. i live in il. or i would be fixen it by hit and miss like thier mech is doin ,i would be cheaper. theyve changed the fuel filter and the connector on the dash (?) for the ign. but nothing helps i keep sug. they change the nuetral safty switch and my mother inlaw states they did this.every nuetral safty switch ive seen has been on the linkage or on the trans. by the way she is 86 and her husband is 89.he is pretty bo. and they need thier van any and all sug. would be app. except the obvious they wont get rid of it.ha ha Replies to this message: jimmj43 (Apr 11, 2008 11:43 pm)
#32 of 37 Re: erratic starts [grummpy] by jimmj43 Apr 11, 2008 (11:43 pm)
Replying to: grummpy (Apr 11, 2008 2:27 pm) Have yoiur MIL do a simple test. Next time she wants to start her Aerostar (especially it's been sitting a day or two), have her just turn the ignition key "ON", and give it about 30 seconds in the "ON" position before she engages the starter. If after the delay it starts right up then chances are the fuel pump (inside the tank) is on its last legs. If the pump's diaphragm has developed "fatigue cracks", those cracks might allow the gasoline in the line to seep back down into the tank. The longer the Van sits idle, the more completely evacuated the fuel line can become - and the longer it'll take to get gas pumped back up the engine where it can do some good.
#33 of 37 column clock spring by aerofan3 Apr 15, 2008 (9:32 am)
I've an 94 Aerostar where the horn, cruise control is not working and the airbag control light is very often on. An electrician stated that I've to change the column clock spring. Ford is charging more than $ 200 for this item, too much for such an old car. I wasn't able to find it researching online the whole sales. Does anybody have an idea where to purchase? Thanks! Replies to this message: wwest (Apr 16, 2008 7:43 am)
#34 of 37 Re: column clock spring [aerofan3] by wwest Apr 16, 2008 (7:43 am)
Replying to: aerofan3 (Apr 15, 2008 9:32 am) The more common problem is not the clock spring itself but the "slip ring" and/or the slip ring brushes. Disconnect the battery, remove the airbag and then the stearing wheel and clean those brush contact points on the "slip ring".   You can sometimes verify "this" being the problem by turning the stearing wheel back and forth, widely, engine running, 15-20 times. That will often "clean" the contact area enough that those functions will work for a few drive cycles.
#35 of 37 Re: ?? Location of [electric] door lock relay ?? [jimmj43] by firealarmguy Apr 27, 2008 (4:19 pm)
Replying to: jimmj43 (Mar 26, 2008 2:35 pm) I put door locks from a 88 areo in my 95 and I think they are by the drivers side kick panel but you simply operate the locks and listen and feel for the relay noise and vibration and the other relay is beside the one that works . good luck pete
#36 of 37 speedometer and interior lights????? by tim222 Nov 22, 2008 (10:13 am)
Inerior lights and speedometer not working someone said it could be the cluster relay switch??? what and where is it? could it call the problem??? please help as I am in dire need!!!!!!
#37 of 37 Re: Headlights [djmjd5] by recondoc Dec 14, 2008 (1:39 am)
Replying to: djmjd5 (Feb 22, 2008 8:21 am) Did you ever get an answer your headlights having a mind of their own? I am having the same problem with my 1993 Ford aerostar. Thanks

Messages Page 4 of 4 1 2 3 4 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums Vans & Minivans Ford Aerostar Ford Aerostar: Electrical Issues