Last post on Nov 13, 2013 at 2:30 PM
You are in the Dodge Dakota-2010 and older
What is this discussion about?
Dodge Dakota, Electrical, Truck
#235 of 509 Re: 1995 Dodge Dakota 2wd 5sp Manual, electrical gremlin [twizted]
Sep 13, 2008 (3:58 pm)
twizted said: I pulled the cable lead for the battery on a NEW alternator, and it still died. I'm frankly open to suggestions on why this might be.
Again - The battery MUST be in the circuit for things to work. Dont forget... the voltage-regulator is IN THE COMPUTER. (not in the alternator like other vehicles)
Do not concern yourself any longer with what happened when you disconnected the battery with engine running... it was an invalid test. (Lets just hope you did not damage somthing in the electrical system)
An easy way to test your alternator while is to go to WallyMart and pick up a digital voltmeter which plugs into the ciggerette-lighter socket. It is a pretty slick little tool to have in your toolbox. Anything less than 13 volts with engine running should be considerd suspect.
#236 of 509 Re: 1995 Dodge Dakota 2wd 5sp Manual, electrical gremlin [bpeebles]
Sep 13, 2008 (4:09 pm)
Noted. I'll pick one up when I grab the battery, prolly also from wallyworld.
And you're right, I should have thought of that, Dodge being the electro-centric system it is, that the issue would not be tested from that, but it's... been a long time since I owned one. Over a dozen years.
#237 of 509 88 dakota intermitant no start
Sep 16, 2008 (4:19 am)
My 88 Dakota at times will not start. I can drive it someplace, shut it off and it may or may not restart. After a period of time (days or hours) it will start. I had it towed to a mechanic and when it got there it started. They couldn't do anything to make it not start. When I got it home it wouldn't start. Later in the week it started. It turns over fine and runs great when it is running.
#238 of 509 Re: 88 dakota intermitant no start [dusty9]
Sep 16, 2008 (4:56 pm)
More details please....when it does not start:
*) does the starter crank the engine?
*)if so, does the engine fire at all?
*)Can you smell raw gasoline at the tailpipe?
#239 of 509 Re: 1995 Dodge Dakota 2wd 5sp Manual, electrical gremlin [twizted]
Sep 19, 2008 (12:16 pm)
I have a 91 2wd 5sp with the same issue. I have had some one read the check engine light and its telling me that the field circuit in the charging system is open. I have replaced the battery and had the alternator tested many times. it is problem that does not show up all the time. I know when the system has stopped charging because the check engine light comes on and the voltage drops. I have measured the field voltage when the system is and is not working. when it is working I am getting around 12.5 volts and at the battery I get 13.6 to 13.9 volts. when it quits working I have no field voltage to tell the alternator to charge. I have tried wiring up an external voltage regulator and that has not worked because I have no field voltage. I have traced all the wires to and from the fuse box looking for an open some where but can not find it. I do not think it is a voltage regulator I believe it is wiring but all the diagrams i have do not cover my truck correctly or completely so I am having a had time finding the issue. has anyone found a fix for this yet like a bad relay or a switch that goes out or what I am lost.
#240 of 509 Re: 1995 Dodge Dakota 2wd 5sp Manual, electrical gremlin [harride]
Sep 19, 2008 (4:16 pm)
You may be missing the point here.... the output of the alternator is REGULATED by adjusting the field-voltage. (a small current in the field circuit can regulate 80+ amps out of the alternator.) There should NEVER be a voltage-regulator on the OUTPUT of the alternator.
You could almost think of the alternator as an AMPLIFIER. Small signal in = large signal out. (As long as it is spun by the engine because that is where the power is coming from!)
With that said, you need to figure out where the voltage-regulator is on your 1995 Dak. On my 2000 Dak, the voltage-regulator is INSIDE the engine-computer. Lets hope you have an external regulator. 8-)
Once you know where the voltage-regulator is, it should be trival to determine where the problem is.
HINT: Many problems such as the one you describe will be traced to a poor ground connection. You may do well to simply disconnect the battery and fix EVERY ground connection you can find on your truck. Pay close attention to engine-to-frame, battery-to-frame and computer-ground connections.
By the word "fix" -- I mean:
1) Remove any screw/bolt holding it down.
2) use fine sandpaper, wirebrush, whatever to clean all contact surfaces.
3) Consider soldering all wires to the ground-connectors.
4)Make certain connection is clean and snugg
#241 of 509 Re: 88 dakota intermitant no start [bpeebles]
Sep 20, 2008 (9:08 am)
No gasoline odor.
#242 of 509 Re: 1995 Dodge Dakota 2wd 5sp Manual, electrical gremlin [bpeebles]
Sep 20, 2008 (2:21 pm)
You know, I'm going to try that next. Here's a recap of my weekend so far:
We had talked about replacing the battery, and I did that. Still the same problem, HOWEVER:
I also, with a fully charged battery, pulled EVERY fuse, inside and out (one in the engine compartment, one under the driver side dash) and checked with a voltmeter if there was a short. NOTHING. Now, I have two batteries I keep fully charged. One to get me where I'm going, and maybe, just maybe, it will not discharge. The other is for the return trip.
You know, another issue that seems to be a part of it, and maybe I need an outside view, is that it seems to run fine until it heats up, then it has problems. it also doesn't like water, or moisture, and ran like hell when the Ike Rain came through here. I know that's just a distributor thing, and I'll address that when I get the other bugs done. Going to do a new distributor, plugs, wires, Dcap. One thing at a time, unless this could be the issue? It HAS to be somewhere in the power transfer through the engine, but... where? Computer?
Given the statements you've made above, I think that's the best possible solution, to check every ground, because it increasingly IS starting to sound like a grounding problem.
I don't have a diagnostic plug on my 95 Dak, but it has the "rev to 2500 RPM, cycle gears, off on off on and count the 'check engine' blinks" internal diagnostic, but I can't find the code that it does. I believe it is the elusive Code 37, which doesn't make sense for the symptoms I'm experiencing. It's either the "Shift indicator light failure, 5-speed" or for 1995 onward "Trans temperature sensor voltage low" which I've been told "This may cause the low (no) voltage indication".
Frankly, I think I'm going to take your advise, and spend a LONG morning/afternoon pulling grounds and getting them sanded, then soldering them on, for good measure. Any idea where I can find a listing, or even better, a diagram, of all the grounds that are SUPPOSED to be in an 1995 Dakota 2WD 5sp engine, 4 cyl?
Like to do this Sunday, probably.
#243 of 509 Re: 88 dakota intermitant no start [dusty9]
Sep 20, 2008 (6:37 pm)
Since you are not smelling any raw gasoline at the tailpipe... I would have to suggest that your FUEL SYSTEM is not injecting fuel. The fuel-pump inside the gastank is KNOWN to cause funky running symptoms when it starts to die. The only real way to test the fuelpump is with a pressure-guage WHILE the problem is happening.
BTW: If you had told me that you WERE smelling gasoline at the tailpipe... that would have suggested an IGNITION SYSTEM issue.
#244 of 509 Re: 1995 Dodge Dakota 2wd 5sp Manual, electrical gremlin [twizted]
Sep 20, 2008 (6:43 pm)
To answer your question : "Any idea where I can find a listing, or even better, a diagram, of all the grounds that are SUPPOSED to be in an 1995 Dakota 2WD 5sp engine, 4 cyl? "
The factory shop manual has detailed drawings showing every ground (chassis) connection on your Dakota. Most of the connections under the hood are easy enough to locate. There is a ground-connection on both sides of the dashboard (near the floor) Lucally, the connections on the interier do not tend to corrode like the ones under the hood.