Ask the Car People.SM


Toyota Sienna Sliding Door Problems

756 messages,  Last post on May 21, 2013 at 12:42 AM

You are in the Toyota Sienna Forum.

What is this discussion about? Toyota Sienna, Car Safety, Van


Go to NHTSA to file a safety complaint.
Or call Monday-Friday (8 am to 8 pm ET) (888) 327-4236 TTY: (800)424-9153

Messages Page 64 of 76

#628 of 756 Re: 2005 Sienna LE sliding door stuck closed [jjllcal] by avery1

Oct 31, 2011 (3:45 pm)

Replying to: jjllcal (Oct 31, 2011 10:05 am)
I think Toyota is making a huge mistake not addressing these issues. I had a Lexus RX300 and there were unaddressed transmission problems with that car. I bought a Volvo to replace it. I didn't even look at the new Lexuses. I also have a 2006 Toyota Sienna. Our door has stopped working via one of the switches so I hope it is just a switch but I am just waiting for the other shoe to drop and be faced with an $1800 bill. If they don't address this problem I will not even look at Toyotas when getting a replacement for this care. And I will make sure my family and friends are aware of the lack of attention. Seems to me to be a bad marketing decision to try and save a few million bucks now but turn off thousands of future buyers.

#630 of 756 Sliding Door problem and brake change! by yifang

Nov 08, 2011 (10:52 am)

Toyota and the dealer is so outrageous with the sliding door problem.
Here is my story:
2005 Toyota Sienna XLE. 110K km the sliding door (driver side) jammed to open, but worked if pull with handle. Went the Ens TOYOTA, charged me ~$500. After 4 months the passenger side of the sliding door had same problem, charged me $709.72!
Complained to TOYOTA Canada. For sure this is the Sienna defect. but I was told it is not under warranty anymore. Paid the bill, total >$1200. Can you believe this?
 
Yesterday, I replaced the front brake, pad/SHIM/FITTING kit ($112.03 parts), but they charged me $367.87 for labors (tax not included!). I phoned back, they said they charged me the job for rear brakes too, which the teller told me when I picked up my car yesterday that job needed another appointment and bill!
I did some research and found here. Now I realized they just suck the customer's blood! Can you believe this!
Why they did this!
 
Then I have a question. Where do I find the standard that the mechanics should charge for the labor for a specific job, so that you can talk to them? Thanks!

#631 of 756 Re: Sliding Door problem and brake change! [yifang] by ateixeira

Nov 08, 2011 (11:31 am)

Replying to: yifang (Nov 08, 2011 10:52 am)
If it makes you feel any better, my buddy just dropped $3000 on a Range Rover with 23k miles for tires and brakes.
 
Yep. Just tires and brake pads/rotors. No warranty help.

#633 of 756 Re: Sliding Door problem and brake change! [yifang] by adiehl13

Nov 13, 2011 (7:16 pm)

Replying to: yifang (Nov 08, 2011 10:52 am)
We also have the 2005 XLE. Blessed with BOTH the door weld "clicking" issue AND just had the driver side sliding door fixed. I don't know the technical term but the cable the door slides on seemed to have rusted out and then s
Got sheared in half. In both cases we were fortunate that for some reason I had signed up for some kind of platinum warranty (which of course we nevr get- knowing Toyota, they probably slipped it in without me knowing. At any rate, the repair would have been $1200.00 as you stated. RIDiCULOUS! I've owned a Toyota since college, but I Swear the next minvan is a Honda. I also hate that I or a passenger can't use the Navi while driving.

#634 of 756 Re: 2006 Toyota Sienna sliding door problem [scottm23] by vmorvillo

Nov 14, 2011 (1:39 pm)

Replying to: scottm23 (Aug 30, 2011 3:26 am)
Question on cutting the cable. How would you get to the cable if the door is stuck in the closed position? I disengaged the auto switch however it is impossible to open the door manually. Would I need to take off the inside door cover to get to the cable?

#635 of 756 Re: 2006 Toyota Sienna sliding door problem [vmorvillo] by wismom

Nov 15, 2011 (3:02 pm)

Replying to: vmorvillo (Nov 14, 2011 1:39 pm)
Have you tried opening the far back passenger window? It won't give you much room, but you may be able to access it that way. Otherwise, yes you'll have to remove the door panel from the inside.
 
My door on my 2005 Sienna XLE was in the open position when this happened and we were able to cut the cable from the outside.
 
I now carry a clipper in the van....just waiting for the other sliding door to malfunction so I can clip that cable as well. UGH.
 
Once the cable is cut, you can manually open and close the door. Better than nothing.
 
This site is helpful too: http://www.siennachat.com/forum/index.php?topic=1631.0
 
And when you're done with that there is actually a Facebook site dedicated to this issue....If 200 folks sign, the administrator is planning to file a class action suit.: http://www.facebook.com/pages/Toyota-Sienna-Faulty-Power-Sliding-Doors/233250320- 033754

#636 of 756 Frustrated Toyota fan by tlambright1

Nov 18, 2011 (3:43 pm)

My 04 Sienna sliding door cable snapped, and they surprised me with a $1500 bill to repair. Options were limited unless I wanted a 3 door van. Six months later, the door no longer works, take it in for adjustment, and they have to replace a different motor. Turns out it's my adjustment, as in $450 more to replace. Out of warranty, so Toyota won't help. I don't pay it, and the previous $1500 spent is worthless. I'm glad there are other strong options for new cars, I'm having a hard time justifying staying with Toyota after 20 years of continuous ownership. Very very frustrating.

#637 of 756 Re: Manual Sliding Door Problems [fix_it_again] by venomjim

Dec 08, 2011 (9:13 pm)

Replying to: fix_it_again (Aug 16, 2011 10:51 pm)
I had this same problem and used the fix you mentioned above. It worked great as far as getting the door to close, but now it won't open. It seems like the cable does not have enough tension to release the rear latch. Do you know how I can get access to the cable to open the door? I think, once I get it open, I can readjust the cable tension or adjust the rear latch mount towards the interior and retighten those two screws.

Messages Page 64 of 76

To POST a message, please Sign In.

Advertisement

Browse by Category

Browse by Vehicle
   View All Vehicles

Browse by Board
Browse by Topic
View All Topics

Edmunds Community

Advertisement