Ask the Car People.SM


Toyota Sienna Sliding Door Problems

756 messages,  Last post on May 21, 2013 at 12:42 AM

You are in the Toyota Sienna Forum.

What is this discussion about? Toyota Sienna, Car Safety, Van


Go to NHTSA to file a safety complaint.
Or call Monday-Friday (8 am to 8 pm ET) (888) 327-4236 TTY: (800)424-9153

Messages Page 64 of 77

#624 of 756 Re: 2005 Toyota Sienna sliding door tough to close [xanderboy] by kristyg

Oct 27, 2011 (4:26 pm)

Replying to: xanderboy (Oct 27, 2011 2:00 pm)
If the problem is the actuator, it is a $100 part that you can purchase from Toyota and install yourself. I don't recall the post numbers but if you search my I'd the references should show up. There are very detailed and easy instructions for installation posted online. I had the same problem with my 2005 sienna and hubby had it fixed in about two hours for only $100! Good luck.

#625 of 756 Re: 2005 Toyota Sienna sliding door tough to close [xanderboy] by jjllcal

Oct 28, 2011 (8:23 am)

Replying to: xanderboy (Oct 27, 2011 2:00 pm)
Check also the L shape hinge ( the part that connected the door to the rail) on the door, the cushion maybe worned out.. It happen to my door and toyota want to replace the motor etc for about $1500. I have it taken care by local machenic for about 200 with part. I hate toyota..I have so many problem with this van. Their cars are not built like before because they use cheap small parts that cause $$$ to fix. Good luck.

#626 of 756 Re: 2005 Sienna LE sliding door stuck closed [tillsonburg] by acaiozzo

Oct 29, 2011 (5:22 pm)

Replying to: tillsonburg (Oct 08, 2010 5:20 pm)
My 2004 is having the same problem - can you please email me pictures of what you did? Thanks! acaiozzoyahoo.com

#627 of 756 Re: 2005 Sienna LE sliding door stuck closed [acaiozzo] by jjllcal

Oct 31, 2011 (10:05 am)

Replying to: acaiozzo (Oct 29, 2011 5:22 pm)
When the l-shape henge (the cushion on the l-shape henge, according to my mechanic) is worn off, it will create a friction when the door is moving. You will have to push the door a little to finish the movement/ or close. However eventually it will start scratching the body of the car and it will stop. There are 2 parts that connect the door to the body, top and bottom. I have problem with the top where the door is hanging. This van has so many problems but toyota will not admit it. On my last visit to toyota for an oil change , the service guy said my brake oil, transmission oil, the gasket are leaking.. it require 6000 to fix. I took it to other mechanic, he said it is just moistures and non of the trouble lights are on. I am not a mechanic but when u hear what the service guy in toyota tell me almost everything is leaking, it really scare me. I really hate them... I used to be a toyota lover.. not any more... good luck.....

#628 of 756 Re: 2005 Sienna LE sliding door stuck closed [jjllcal] by avery1

Oct 31, 2011 (3:45 pm)

Replying to: jjllcal (Oct 31, 2011 10:05 am)
I think Toyota is making a huge mistake not addressing these issues. I had a Lexus RX300 and there were unaddressed transmission problems with that car. I bought a Volvo to replace it. I didn't even look at the new Lexuses. I also have a 2006 Toyota Sienna. Our door has stopped working via one of the switches so I hope it is just a switch but I am just waiting for the other shoe to drop and be faced with an $1800 bill. If they don't address this problem I will not even look at Toyotas when getting a replacement for this care. And I will make sure my family and friends are aware of the lack of attention. Seems to me to be a bad marketing decision to try and save a few million bucks now but turn off thousands of future buyers.

#630 of 756 Sliding Door problem and brake change! by yifang

Nov 08, 2011 (10:52 am)

Toyota and the dealer is so outrageous with the sliding door problem.
Here is my story:
2005 Toyota Sienna XLE. 110K km the sliding door (driver side) jammed to open, but worked if pull with handle. Went the Ens TOYOTA, charged me ~$500. After 4 months the passenger side of the sliding door had same problem, charged me $709.72!
Complained to TOYOTA Canada. For sure this is the Sienna defect. but I was told it is not under warranty anymore. Paid the bill, total >$1200. Can you believe this?
 
Yesterday, I replaced the front brake, pad/SHIM/FITTING kit ($112.03 parts), but they charged me $367.87 for labors (tax not included!). I phoned back, they said they charged me the job for rear brakes too, which the teller told me when I picked up my car yesterday that job needed another appointment and bill!
I did some research and found here. Now I realized they just suck the customer's blood! Can you believe this!
Why they did this!
 
Then I have a question. Where do I find the standard that the mechanics should charge for the labor for a specific job, so that you can talk to them? Thanks!

#631 of 756 Re: Sliding Door problem and brake change! [yifang] by ateixeira

Nov 08, 2011 (11:31 am)

Replying to: yifang (Nov 08, 2011 10:52 am)
If it makes you feel any better, my buddy just dropped $3000 on a Range Rover with 23k miles for tires and brakes.
 
Yep. Just tires and brake pads/rotors. No warranty help.

#633 of 756 Re: Sliding Door problem and brake change! [yifang] by adiehl13

Nov 13, 2011 (7:16 pm)

Replying to: yifang (Nov 08, 2011 10:52 am)
We also have the 2005 XLE. Blessed with BOTH the door weld "clicking" issue AND just had the driver side sliding door fixed. I don't know the technical term but the cable the door slides on seemed to have rusted out and then s
Got sheared in half. In both cases we were fortunate that for some reason I had signed up for some kind of platinum warranty (which of course we nevr get- knowing Toyota, they probably slipped it in without me knowing. At any rate, the repair would have been $1200.00 as you stated. RIDiCULOUS! I've owned a Toyota since college, but I Swear the next minvan is a Honda. I also hate that I or a passenger can't use the Navi while driving.

Messages Page 64 of 77

To POST a message, please Sign In.

Advertisement

Browse by Category

Browse by Vehicle
   View All Vehicles

Browse by Board
Browse by Topic
View All Topics

Edmunds Community

Advertisement