Edmunds.com | Inside Line | Auto Observer Your Account | Help | Directory
You are here:
![[F]](http://a332.g.akamai.net/f/332/936/12h/www.edmunds.com/media/townhall/webxicons/site.gif){kind=small}
Forums
Vans & Minivans Toyota Sienna Toyota Sienna Sliding Door Problems
324 messages, Last post on Nov 21, 2009 at 6:43 PM
You are in the Toyota Sienna Forum. Your Host is Karens
|
Replying to: singh05 (Jun 30, 2009 6:17 pm) NHTSA's ODI (Office of Defects Investigation) link is here: http://www-odi.nhtsa.dot.gov/ivoq/index.cfm Go there to file a complaint. If they see a pattern, i.e. enough people complain, a manufacturer will be forced to do a recall. |
|
|
|
|
Replying to: skijenn (Apr 26, 2009 6:13 am) |
|
|
I have a 2006 Sienna. My back door is manual on the drivers side. When I open the door it will not latch. There's a lever that stays open and hit something before the door can open completely and latch. I can't figure out what closes that latch to close. You can move the latch assembly by loosing the bolts, but it hasn't helped. Can someone help? Sopman |
|
|
Both sliding doors (manual) on my 2006 Sienna (60K miles) are next to impossible to open from the interior side. Sometimes, if I snap the handle back quickly, the door will unlatch. This problem started about a year ago and has gotten progressively worse. The outside latches are difficult to operate too but will eventually get the doors open. (They certainly don't operate like my neighbor's Odyssey). I'm now very uncomfortable with having passengers who may not be able to get out of the van without outside assistance. This is a potential safety hazard. I've posted this problem on the NHTSA site. I think the problem is within the latch mechanism. Maybe it just need lubricant. Neither door gets much use, especially the driver side slider. It surprises me that both started failing at the same time. Leads me to believe that something has aged out, like lubricant or a rubber part.
|
|
|
Lubrication is worth a try. On my 04 Sienna it didn't work. I found that the plastic coating on the latch that is located in the door that is supposed to fasten itself around the u shaped striker on the door frame was sticking. Not because of lack of lubrication but because the plastic coating had swelled up from rust buildup inside itself. I think Toyota plastic coated them to make them quiter. But unless you made the latch out of something that wont rust, once it wears through the plastic, rust builds up and swells up the latch and no amount of lube will help. Another problem is the door seals they freeze up in the winter and also stick on hot days. Actually when doors fail to open, they present a danger to passengers in the rear if an emergency bailout is necessary. I have had the doors appear to be latched and then start driving down the road and the door open warning light comes on. Not great when you have young children in back. And it appears the cause is not that the door isn't shut properly but that the latches don't fully latch. |
|
|
Replying to: owego (Jul 25, 2009 7:58 am) In winter they would freeze shut, you could not open them. I had lubricate put on that did not work, they Dealer changed door seal 2 or 3 times, finally they replaced seals with ones from "CAnada" I guess it colder up there. Anyway after 5 or 6 trips to dealer I finally got it fixed. |
|
|
|
I have a 2009 sienna both driver and passenger sliding doors are manual and when you open them they will not stay open most of the time. Its like the spot were they slid into and lock locks before the door is their. It is very annoying and somewhat painful to have the doors keep sliding on you while you are trying to load kids and other things into the van. We have taken it to the dealer twice, (we have only had it 6 months) and of course the doors work perfectly fine at the shop and as soon as I get home from the shop they wont stay open. They say they can't fix what they can't see. I feel that it is pretty obvious that the sensors in the door are not working. We paid extra for all the stupid warrenties. I wish they would just fix it. Is anybody else having a similar problem?
|
|
|
Replying to: totallyannoyed (Jul 29, 2009 12:47 pm) |
|
|
|
|
Replying to: totallyannoyed (Jul 29, 2009 12:47 pm)
|
|
|
Replying to: fix_it_again (Aug 09, 2009 9:25 pm) This is obviously a safety hazard. God forbid someone is injured or dies, I think Toyota will have a class action negligence lawsuit on their hands. I've contacted the NHTSA and also e-mailed my concerns to Toyota. I suggest you all do the same!
|
|
You are here:
Forums
Vans & Minivans Toyota Sienna Toyota Sienna Sliding Door Problems
New? Join Now!
Forum Tools
Search Forums
Browse by Vehicle
2011 Toyota Sienna
Browse by Board
Browse by Topic
Today's Chats
