Last post on Oct 20, 2009 at 8:56 AM
You are in the Saturn S-Series
What is this discussion about?
Saturn S-Series, Fuel System, Coupe
#12 of 39 Re: Saturn fuel problem? [jaritars]
Feb 11, 2007 (11:24 am)
I recently bought a used 1997 Saturn SW2 and it has some of the same problems I've just read here. It sometimes gives me a hard time starting up (although it always does) and sometimes jumps a bit when I first press the gas. Nothing showed up in my last tune up and I guess I'm not too concerned about that yet.
My real problem is that I seem to be getting terrible city gas mileage. I'm supposed to get something like 26 mpg and I'm getting about 17 mpg! Any thoughts on what might be causing this?
#13 of 39 97 Saturn SL2 fuel problem?
Feb 14, 2007 (9:09 am)
I have a 97 SL2 with 153000 on it. Just recently the "low fuel" light will come on and the gas gauge will drop below empty and then reset back to where it was before. The tank is half full when this happens. Could this also be linked to the coolant temp. sensor? Thanks for any help
#14 of 39 99 SATURN SC2
Feb 15, 2007 (8:33 am)
I JUST REPLACED MY BATTERY AND NOT MY CAR IDLES HEAVY AND SHUDDERS. MY RPM'S DANCE UP AND DOWN WITH NO PATTERN. IN TI HAVE TO REV THE ENGINE TO KEEP IN RUNNIG WHILE IN NUET OR DRIVE. WHEN IN PARK IT'S FINE !. THERE ARE CASES WHEN THE RPMS DROP SO LOW AT EVERY STOP SSIGN OR STOP LIGHT THAT IT SHUTS OFF OR DOES NOT MOVE WHEN PRESSED ON THE GAS.
Jul 11, 2007 (9:13 am)
My car studders and cuts off,the rpms go up and down as if getting something out of system,it will idle high for a second then return to normal,it drives great at times,I've replaced the fuel filter,spark plugs and wires oil and air filters,I've cleaned and checked the coils,I've added fuel injection cleaner and gas treament and lucas' oil and engine treatment,can someone help me figure out what's wrong,is it maybe a injector,a sensor,or do I need to replace my coil pack altogether,and when it stall and I carnk it back up,it kicks some white smoke out the muffler but I can't quite place the smell,and my engine runs hot while idling,and returns to normal once I move,oh and get this,it passed inspection with flying colors 4 days ago,help before I go crazy
#16 of 39 1993 sc2 fuel gauge dosnt work
Jul 11, 2007 (11:39 pm)
my sc2 i just baught the fuel gage dosnt work on it i checked all the fuses what else could it be
thank you for you time guys i know its a dumb question
#17 of 39 Re: 97 Saturn SL2 fuel problem? [avw72]
Jul 15, 2007 (4:55 am)
Did you ever find out what the problem was with the low fuel light? Your answer might help me troubleshoot a problem. Thanks, Joe
#18 of 39 I,m BACK like a chiropractor....
Jul 15, 2007 (7:16 pm)
Not even a week ago I posted a ad about my 92 saturn sl1 sohc,I had a problem that I think alot of others did too...what I am about to tell you will save every owner with same year and model,look up the year bracket to see if this applies to your model that you'd benefit from.now I'm the second owner,I bought it a month ago for 500 and also 154k on the engine,prior to my purchase of this car,the former owner of the car informed me that it sat in his yard for a year,so you can imagine,the car ran great but it would put during moving,stopped,or at a light,it would stall intermitantly,and I replaced the fuel filter thinking it had water in the tank and it ran thru the system,no change,then I thought my spark was weak so I changed all plugs and wires,oil and air filters,the engine performance did increase from sluggish to haulin ass,I was shocked! However it did not stop the putting.ok now I'm worried cuz I didn't have a clue,so after talking it over with a few mechanics,logging onto saturn.com,autozone.com,I am telling you,these sites saved me 1,500 in labor,with all 3 sources of info I knew that i had to take matters in my own hands.you don't have to buy the saturn repair manual like I did,autozone.com kills the book on all levels,user friendly.so I went over my problems in the book,I knew it was clogged somewherejust where and how's it effecting my acceleration?I did buy a volt meter for 7 bucks,the investment paid for itself tenfold,the book and website tell you to check every major electrical sensor and unit,so it eliminates having to guess,if the said units volts don't meet specifications,replace it..except all my engine components were good,so I was puzzled,I plugged it up to a computer OBD and it gave me the old codes saying my throttle body intake was too lean,IAC valve low output,idle air control valve,ERG vavle,engine return gas valve,PCM/tc = your cars computer,then it gave me 3 new codes,2 of which I took care of,but the PCM/tc remained,I was bombed out thinking wow I bought a lemon but before I would think negative about the man I bought it from,I compared the info that I now knew to the codes on my saturn repair manual,to the autizone website I had developed a new blueprint,I just read and visualized how the system generated the things that were now my problems,I bought carburator cleaner,and non flammable parts spray,by the way you can spray it on wires too,I worked great in preparing the engine for my inspection,after removing the air flow system I took off the housing to show the throttle body,when I tested the voltage on the IAC idle air control valve and it was on the money,I thought I may have to replace it due to rough idling,high engine revs,and stalling,but no,upon checking the coonector it looked like somebody put gum in it,a handful,and I am such a rookie I never knew the throttle body wasn't copper or penny like,I just tap sprayed around it and wouldn't you know it looked like grey/chromish,I twisted the throttle with my hand to turn the throttle as if to push your foot on the gas,sprayed down there a bit,be careful to hold the throttle open when you spray or it will fly back in youe eyes,the body on the throttle is only 2 inches deep,not a lot so be careful,remember,tap spray,don't spray the whole can,avout 2oz. Is more than enough,keep in mind,there are 4 little holes in the throttle body.the 2 on top are about the size of a period at the end of a sentence,and the blow vapors of fuel into the body along with the systems primary injector,the 2 bottom catch uneeded flow and recycles it so fast you can't se it,I promise you my car runs like I bought it off the lot,super fast and very responsive,all it took was a can of carb cleaner,for my car to drive good,and I'm sure the guys meant well at the shop,they saw the OBD reader as did I and were prepaired to replace everything,I mean was the computer drunk or high?lol...it would have cost me 700 for the computer,99 for erg valve,throttle body sensor 59 and like 500 in labor and that was with a 200 discount 1,500 total that I saved from a investment of 20 on the manual,2 on carb cleaner, 22 out of pocket on top of the 300 in already put into the car,all the tools I needed were a phillips screw driver, a small socket to take off 1 bolt on the air flow housing,that aint sh#t!!! Come on my satuern brotheren and sistereth,be smart and don't be afraid to check the car,you gotta talk to her,I was never once embarassed when she stalled on me,I just had to talk to her like,"baby,soon as I get you to the house,imma take care of it"and I did,I live in a development were all the children play with mine,so I have met a lot of mothers and fathers,they all see my work and have even paid for my repair work,you all can do it too,be smart and don't be taken advantage of,cuz they get over on you,if it was my computer my car wouldn't have run as good as it did when it ran,I put 800 miles on it first then I fixed it,the car looks good,runs great,and has many extras,its currently beind advertized on myspace for sale,I'm going to but a suv,but this is the 2nd saturn I've owned,and they're dependable...take care and be safe,hit me up if you need any advice,I'm located in woodbury nj and will travel if you're paying,I charge less than everybody,I stand by my work
#19 of 39 93 Saturn SC idle problem
Dec 27, 2007 (3:25 pm)
My idle is sticking. For example, between shifts while I'm driving, the RPM's don't drop back to normal all the time. When I come to a stop the idle is very slow to return to normal. The car has 183,000 miles and otherwise runs great.
Please offer some suggestions.
#20 of 39 Special Policy: 1997 Saturn Fuel Pump Failure
Dec 30, 2007 (2:47 pm)
Has anyone had experience with this? I bought my '97 SL1 in Sep 1999 with 24K miles. By Nov 1999 I was already having problems with it starting hard, or starting and running then dying suddenly. Saturn Svc was unable to verify/duplicate problem: No codes, battery OK, PCM Temp Sensor reading properly. In April 2000, I received a letter from Saturn Corp re their "Special Policy relating to 1997 model year Saturn vehicles. The fuel pump... may fail prematurely and cause extended crank time, loss of power, and possible no-start conditions." Saturn would provide fuel pump replacement [at no cost]... for six years from [original service date] or 75,000 miles, whichever comes first." For me, that meant Aug 2002 or another 50,000 miles. It goes on to say if you have already experienced such problem and paid for fuel pump replacement, Saturn will reimburse you. I should have taken it in then, but my daughter was using the car away at college and had not complained about the problem for awhile. In Sep 2002 (39,00 miles), an electrical problem reared it's ugly head and the generator assembly was replaced. In Dec 2002, the cold start problem returned w/rough idle and engine vibration. Saturn Svc diagnosed this as "torque axis mount collapsed", whatever that is. Sounds more like a result of the problem than a cause. So where are we going with this? Well in Mar 2003, with only 57,000 miles, my daughter was driving the car at highway speeds, the car began to lose power, she stepped on accelerator but it continued to slow until it died. Saturn Svc (different dealer) diagnosed that the "timing chain jumped time and bent all the valves." The engine was basically destroyed. Replacement with used engine, exchanged parts, and labor cost her $1,944. Granted this occurred well beyond the extended warranty, and my luck, just 6 months beyond the Special Policy replacement period, but it seems to me that Saturn should be partly responsible for this and reimburse my daughter some of this expense. What would cause the timing chain to jump time and destroy the valves? My guess is fuel pump failure at highway speeds. If Saturn Svc had correctly diagnosed this problem the year before, this would probably not have happened. Before I take my case to Saturn Customer Assistance, I wanted to know if others have dealt with this and what you think of my argument. Thanks for allowing me to rant.
#21 of 39 97 saturn lemon
Mar 20, 2008 (2:44 pm)
P0404 and Po221 codes --egr and tps replaced all with exception EGR. cleaned throttle body -comes on usually after sticking aand fuel low. Sometimes put gas in and shuts off -new gas cap. I tried something I took off gas cap and pressed in valve and put cap on and it went off.prev cleaned EGR.TO THE DUMP