Last post on Jul 08, 2013 at 8:41 AM
You are in the Chrysler Town & Country/Dodge Grand Caravan
What is this discussion about?
Chrysler Town and Country, Plymouth Voyager, Auto Repair, Van
#4 of 26 Re: Squealing serpentine belt 1996 town and country [glynch]
Aug 12, 2006 (5:22 pm)
If the tensioner is ok I recommend you replace the Mopar belt with a Dayco or other brand name. I always had the dealer replace the belt and never had any problems for 96k until the last change. Then it came off in an inch of rain and squealed for no reason. I had a tsb done for $250.00 which did nothing. After the last tow to the dealer I had them install a standard Dayco belt that I had purchased and it hasn't come off since.
#5 of 26 Re: Squealing serpentine belt 1996 town and country [mrbizness1]
Aug 15, 2006 (7:00 am)
I just don't understand why this is such a problem now. There must be something causing it.
#6 of 26 Re: Squealing serpentine belt 1996 town and country [glynch]
Aug 20, 2006 (9:39 am)
I read somewhere that the newer Mopar belts have deeper grooves which can hold water, and make the belt squirm. They also could be a bit longer, so they don't have enough tension. Looking at my dealer invoices from a few years back I noticed that the belt part number is different. The dealer said they newer belts are updated, but they don't know what the difference is. It's been almost a year and the Dayco belt hasn't come off once.
#7 of 26 Re: Squealing serpentine belt 1996 town and country [mrbizness1]
Aug 28, 2006 (5:58 am)
You should buy some spray can with 'belt dressing' It will cost you between $5.00 and $10.00 at an automotive parts store, and I find that it helps usually for many months. WD-40 is ok but doesn't last as long.
#8 of 26 Re: Squealing serpentine belt 1996 town and country [willem]
Aug 28, 2006 (3:10 pm)
I wouldn't recommend belt dressings or lubricants, especially on a serpentine belt system. The dressing attracts dust and debris. It also serves to brake down the rubber in the belt. Short term fix, very short.
Its possible that the squeal is not related to the A/C compressor, just coincidental. Have them check the P/S pump or water pump as well as the alternator. Good luck!
#9 of 26 Replacing 2002 Voyager Serpentine Belt
Jul 19, 2007 (7:34 am)
Does anyone know how to take the tension off the serpentine belt of a 2002 voyager, 3.3L flex fuel V6? I can easily access the tensioner from below and it seems like you need to insert a 1/2 inch socket square drive into a square hole at the pulley end of the tensioner to lever it down. However there is not enough space between the tensioner bracket and a frame member to get the square drive into the hole. Am I wrong about doing it this way? How should it be done?
#10 of 26 Re: Squealing serpentine belt 1996 town and country [glynch]
Jul 23, 2007 (5:32 am)
The Gates company has a fix kit for the belt problem on Chrysler 3.3L & 3.8L engines. Cost is about $140. I had the fix kit installed on my 1998 Chrysler Town and Country and I've had no problems yet. Prior to this fix, any puddle I drove through would cause the belt to slip off.
#11 of 26 electrical oddity following jump start
Jul 23, 2007 (6:40 am)
The battery on my 1998 Chrysler Town and Country ran down (due to my own stupidity) and I jump started the car. After jump starting the car, the indicator lights for the air conditioner, recirculation, rear window wiper and rear window wiper washer all are blinking. They stop blinking if I drive the car about 15 minutes, but when I start the car again, the blinking begins again. Any ideas?
#12 of 26 1998 Town and Country
Jul 28, 2007 (5:33 pm)
Can anyone please tell me how to replace my belt tensioner? I have looked in my repair manual to no avail. Any help would be greatly appreciated.