You are here: Forums SUVs Isuzu Trooper Isuzu Trooper Maintenance and Repair

Isuzu Trooper Maintenance and Repair

313 messages,  Last post on Nov 23, 2009 at 5:10 PM

You are in the Isuzu Trooper Forum. Your Hosts are steve_ & tidester

What is this discussion about? Isuzu Trooper, Isuzu Trooper II, SUV

Messages Page 27 of 32 1 ... 24 25 26 27 28 29 30 ... 32 Prev Next Last

Go To Msg # Search This Discussion

#258 of 313 water pump by cmartman46 Nov 22, 2008 (9:58 pm)
Not sure of the size of star socket,probably a 12 mm. Drain,antifreeze,Remove hoses, remove radiator,fan stroud, fan and pully.Serpenten belt removed. Air condition and power stering pump and brackets move out the way.Remove all bolts and nuts..Tap on pump with rubber mallad.Match pump to new one. Clean all mating surfaces real good.And assemble in reverse with new gasket. Get a manuel if in doubt.Good luck!
#259 of 313 window regulator - plastic rollers by scottpod Nov 27, 2008 (6:58 am)
Is there a replacement part avaialble for just the plastic/nylon rollers that the regulator arms pop into? These rollers roll in the track that is attached to the bottom of the window in my 1996 trooper with power windows. One of mine are cracked and it makes it so one of the arms pop out. If it is an entire unit, can you suggest a source for the entire unit. Replies to this message: troopernate (Nov 27, 2008 12:22 pm) viking66 (Dec 24, 2008 7:00 am)
#260 of 313 Re: window regulator - plastic rollers [scottpod] by troopernate Nov 27, 2008 (12:22 pm)
Replying to: scottpod (Nov 27, 2008 6:58 am) try myisuzuparts.com   they have alot of diagrams too. Replies to this message: viking66 (Dec 24, 2008 7:00 am)
#261 of 313 how to remove fuel pump on 93 trooper by viking66 Dec 24, 2008 (6:48 am)
I have the tank off, There are about 8 screws on top of tank where the fuel pump assembly is. They are all rusted, how do i get the pump assembly out of the tank. Do i unscrew these or do i unscrew the intire unit ..
#262 of 313 Re: window regulator - plastic rollers [troopernate] by viking66 Dec 24, 2008 (7:00 am)
Replying to: troopernate (Nov 27, 2008 12:22 pm) the diagrams do not show how it comes appart, it only shows it in parts.. I dont know if it was unscrewed from the tank as a whole or if the 8 screws were what holds in on.. they are not usable.. they are rusted so bad a screw driver will not bite on them..
#263 of 313 1990 Trooper dies by JoeGrassyCreek Jan 07, 2009 (3:17 pm)
My 1990 Trooper runs fine for a while, and then it periodically just dies. All of the warning lights come on, and it's like some one just flipped a switch and turned it off. It has power to all circuits, except there is no spark at all to the spark plugs.   There is no pattern to this that I can discern. Sometimes it runs for three or four months before it does it. Sometimes it's a day. Sometimes it won't start for a week or more, and other times it will start back up in a few minutes. It does it in dry weather and wet. It does it when it's hot and when it's cold.   I have replaced all of the relays and the coil.   Anyone have any idea where to look next?
#264 of 313 91 trooper starting problem when warmed-up by mlgsr Jan 07, 2009 (4:06 pm)
I have a 1991 trooper with 6cyl. It will start ok in the morning and run right, but after it gets warm, it is hard to start again. I normally just use starter fluid to get it going, but even that is getting hard. When that fails, I can just let it sit for a while and it will start and run ok ... till i shut it off again. I tried replacing the fuel filter, but no difference, and I have the error codes but can't find what they refer to.   #'s = 32, 34, 43, 54   any suggestions?   thanks   mike
#265 of 313 93 trooper radiator by marcocruz Jan 16, 2009 (7:17 pm)
I am installing a new radiator.I need to remove the transmission cooling lines.What size flare wrench do I need?Any other advise ,as well ,would be appreciated.thanks.
#266 of 313 Re: Oil Consumption '02 Trooper LTD [jake1216] by muttley1 Jan 19, 2009 (10:06 pm)
Replying to: jake1216 (Feb 25, 2008 11:04 pm) Did you ever receive any replies? I have two 2002 Troopers, and neither seems to burn too much oil. Have only had them for a year or so each, and both have less than 50k miles. This is a concern I have seen raised before, with no clear answers as I recall - other than check the level regularly.
#267 of 313 replacement seat belt by jbourne3 Feb 13, 2009 (4:41 pm)
does anyone has any instruction or know where I can find instruction on how to replace driver side seat belt? i have a 2000 isuzu trooper LS. Many thanks   Jason

Messages Page 27 of 32 1 ... 24 25 26 27 28 29 30 ... 32 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums SUVs Isuzu Trooper Isuzu Trooper Maintenance and Repair