You are here: Forums Sedans Chevrolet Malibu Chevrolet Malibu Climate Control/AC Issues

Chevrolet Malibu Climate Control/AC Issues

132 messages,  Last post on Aug 20, 2009 at 7:12 AM

You are in the Chevrolet Malibu Forum. Your Hosts are pat & karens

What is this discussion about? Chevrolet Malibu, Chevrolet Malibu SS, Heating / Cooling, Sedan

Messages Page 14 of 14 1 ... 8 9 10 11 12 13 14 Prev Next Last

Go To Msg # Search This Discussion

#124 of 132 Re: 2004 Malibu Classic [epoland] by meethos Jun 11, 2009 (4:44 pm)
Replying to: epoland (Apr 22, 2009 7:19 pm) very easy to do, only took me 30 min the first time I took it off. First you start off by pulling the black trim(this is what covers the climate control unit, radio, ignition cigarette lighter) away from the dash board; I just used my fingers. Then I had to put the key in the igniton so I could move the gear shift back(did not have to start the car to do this) so I could completely remove the trim piece; I disconnected the wiring harness from the cigarette lighter. From there you will see two bolts that hold the unit in place, I just used a 7 mm socket to undo the bolts and the unit just came off, there will be four connections on the back of the unit, just make note of how the vaccum hoses are connected. Then follow the instructions below to disassemble the control unit.   http://www.imcool.com/articles/aircondition/AC_ControllersAreRepairable.pdf
#125 of 132 Re: fixing malibu intermittent ac on 99 malibu [tootal2] by edarmenta Jun 28, 2009 (10:59 am)
Replying to: tootal2 (Apr 13, 2008 6:05 pm) I'm trying to read your post. What two items did you replace to fix the intermittent ac. Was it the resisetr or the main control module in front of tehd ash.? Thanks
#126 of 132 Re: 2004 Malibu Classic [meethos] by davidlittle04 Jun 30, 2009 (5:44 pm)
Replying to: meethos (Jun 11, 2009 4:04 pm) What part was it that you replaced? I looked and found the climate control console piece (part with knobs) for about $30 bucks. Was that the part, or is it something inside the dash, or was it a resistor, or what? Thanks so much!   Dave Replies to this message: meethos (Aug 01, 2009 10:20 am)
#128 of 132 Re: 2004 Malibu Classic [epoland] by hop2 Jul 16, 2009 (11:40 am)
Replying to: epoland (Apr 22, 2009 7:19 pm) I have a 2005 Malibu LS   and I would like to know how to take that control panel out. I have been led to believe the whole dash-panel has to be removed, and I don't feel like going that far. I can't believe they were that stupid as to make it that unaccessable.
#129 of 132 2004 Malibu by tkarr Jul 26, 2009 (1:11 pm)
Hi, I have the same problem with my 2004 Malibu. I had it replaced in 2006 under warr. After about 2 yrs, the AC light started blinking and it would go from recirrculating to fresh air. Last year on 7/24/08, I had it changed again and I paid for it! $480 bucks! Now, only a year later, it is doing it again and of course it is out of the Warr periode. If this is a big problem, why doesn;t Chevy do something about it!
#130 of 132 Re: 2004 Malibu Classic [davidlittle04] by meethos Aug 01, 2009 (10:20 am)
Replying to: davidlittle04 (Jun 30, 2009 5:44 pm) david, it was the whole unit; and it only cost me $30 bucks. It came as a whole unit, just unplugged the old one and replaced.
#131 of 132 AC air vent selector switch by 4chevys Aug 19, 2009 (2:30 pm)
I have a 2000 Malibu and the air coming out of the AC does not blow where you have it set. It mostly blows from the floor vents. I have looked for a vacuum leak but cant find one. Should I try cleaning the switch? Replies to this message: gonogo (Aug 20, 2009 7:12 am)
#132 of 132 Re: AC air vent selector switch [4chevys] by gonogo Aug 20, 2009 (7:12 am)
Replying to: 4chevys (Aug 19, 2009 2:30 pm) The switch o-rings might be worn, I think your on the right track.

Messages Page 14 of 14 1 ... 8 9 10 11 12 13 14 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums Sedans Chevrolet Malibu Chevrolet Malibu Climate Control/AC Issues