Last post on Mar 05, 2012 at 10:02 AM
You are in the Chevrolet Malibu
What is this discussion about?
Chevrolet Malibu, Chevrolet Malibu SS, Heating / Cooling, Sedan
#122 of 151 Re: 2004 Malibu Classic [epoland]
Apr 29, 2009 (6:26 am)
was you able to fix it ?
#123 of 151 Re: 2004 Malibu Classic [redirish]
Jun 11, 2009 (4:04 pm)
Woo Hoo.....was finally able to fix mine for the time being. I found a used unit on Ebay($30 compared to $300); swapped out the climate control unit and it started working again.
#124 of 151 Re: 2004 Malibu Classic [epoland]
Jun 11, 2009 (4:44 pm)
very easy to do, only took me 30 min the first time I took it off. First you start off by pulling the black trim(this is what covers the climate control unit, radio, ignition cigarette lighter) away from the dash board; I just used my fingers. Then I had to put the key in the igniton so I could move the gear shift back(did not have to start the car to do this) so I could completely remove the trim piece; I disconnected the wiring harness from the cigarette lighter. From there you will see two bolts that hold the unit in place, I just used a 7 mm socket to undo the bolts and the unit just came off, there will be four connections on the back of the unit, just make note of how the vaccum hoses are connected. Then follow the instructions below to disassemble the control unit.
#125 of 151 Re: fixing malibu intermittent ac on 99 malibu [tootal2]
Jun 28, 2009 (10:59 am)
I'm trying to read your post. What two items did you replace to fix the intermittent ac. Was it the resisetr or the main control module in front of tehd ash.?
#126 of 151 Re: 2004 Malibu Classic [meethos]
Jun 30, 2009 (5:44 pm)
What part was it that you replaced? I looked and found the climate control console piece (part with knobs) for about $30 bucks. Was that the part, or is it something inside the dash, or was it a resistor, or what? Thanks so much!
#128 of 151 Re: 2004 Malibu Classic [epoland]
Jul 16, 2009 (11:40 am)
I have a 2005 Malibu LS
and I would like to know how to take that control panel out. I have been led to believe the whole dash-panel has to be removed, and I don't feel like going that far. I can't believe they were that stupid as to make it that unaccessable.
#129 of 151 2004 Malibu
Jul 26, 2009 (1:11 pm)
Hi, I have the same problem with my 2004 Malibu. I had it replaced in 2006 under warr. After about 2 yrs, the AC light started blinking and it would go from recirrculating to fresh air. Last year on 7/24/08, I had it changed again and I paid for it! $480 bucks! Now, only a year later, it is doing it again and of course it is out of the Warr periode. If this is a big problem, why doesn;t Chevy do something about it!
#130 of 151 Re: 2004 Malibu Classic [davidlittle04]
Aug 01, 2009 (10:20 am)
david, it was the whole unit; and it only cost me $30 bucks. It came as a whole unit, just unplugged the old one and replaced.
#131 of 151 AC air vent selector switch
Aug 19, 2009 (2:30 pm)
I have a 2000 Malibu and the air coming out of the AC does not blow where you have it set. It mostly blows from the floor vents. I have looked for a vacuum leak but cant find one. Should I try cleaning the switch?