Edmunds.com | Inside Line | Auto Observer Your Account | Help | Directory
You are here:
![[F]](http://a332.g.akamai.net/f/332/936/12h/www.edmunds.com/media/townhall/webxicons/site.gif){kind=small}
Forums
Sedans Chevrolet Cavalier Chevrolet Cavalier: Head Gasket Issues
58 messages, Last post on Oct 09, 2009 at 7:36 AM
You are in the Chevrolet Cavalier Forum. Your Hosts are pat & karens
|
I am the original owner of a 98 cavalier. It was problem free for many years, but in the last 2 years it has had issues. The latest is overheating. I hadn't gone 3 miles from home when a light came on the dash showing low coolant, then within 3-4 minutes the needle on the temp gauge went over to H when it normally is right in the middle between C and H. So, I pulled over and turned the car off. After it cooled off I looked in the water resevoir and it was empty, so I added some water and was able to drive it to a mechanic without the light coming on again or the needle going to H. After a day with the car, the guy tells me nothing is wrong with it. Charged me $85 for that information. I drove it home and the next day all that water I added and I guess antifreeze was now on the ground in my garage. I added more antifreeze/water and took it out and the dash light came back on. Long story short, I had another mechanic look it over and he pressure tested the system and told me the water pump was leaking, a sensor that makes the fan come on was bad and the sensor wasn't switching the fan on, and I might have a blown head gasket. He replaced the water pump, he replaced the thermostat, replaced the sensor, he flushed the system and added some sealer - I think he called it Red Devil -- and said it was a temporary fix for a head gasket problem. He drove it around and said he thought it was ok for awhile. I am a nervous wreck now to drive it. I figure I'll have to get that gasket replaced eventually, but how long do you think I have? I'll need to save money in order to get it done, otherwise I would have had him do it today. Is it possible that the water pump could have been the big problem or is it definitely a head gasket problem when the coolant leaks and the car temp gauge goes to H?
|
|
|
|
|
Replying to: bella14 (Jul 20, 2008 4:31 pm) In any event, perhaps the repairs done will fix the problem. If the head gasket is in fact leaking, you won't get far with the car. In the future, the proper tests for a head gasket leak are: 1. pressurize the system, remove spark plugs and inspect 2. inspect the oil for water intrusion 3. test the radiator coolant for combustion gases with the proper tester 4. compression test that shows two low adjacent cylinders 5. white smoke out of exhaust pipe 6. rapid overheating
|
|
|
Replying to: Mr_Shiftright (Jul 22, 2008 10:34 am)
|
|
|
|
|
Replying to: bella14 (Jul 24, 2008 12:22 pm) The general rule, to which there are exceptions, is that if you have a low speed overheat, that is, when the car is barely moving, you have an AIR circulation problem, (non-working fan for instance) and if you have a high speed overheat, that is when the car is moving fairly rapidly, you have a coolant circulation problem. (clogged radiator, stuck thermostat).
|
|
|
Replying to: Mr_Shiftright (Jul 24, 2008 4:41 pm) I brought it to the mechanic last night for him to look at the fan -- (to show me where it was actually) He is a friend's brother in law, so I do believe that he is honest. After the engine cooled down I checked and the coolant is staying in the resevoir -- no more big leakage in my garage yet the temp gauge climbs past halfway while driving in stop and go traffic under 50 miles an hour. I was very nervous seeing it climb past the halfway point since it never used to do that. He checked it and showed me the fan was going while the A/C was on. Then he turned the A/C off and we waited and waited to see when or if the fan would kick back on by itself. It did eventually. So it seems not to be a fan problem. He said the temp outside has something to do with how hot an engine gets, and living in Florida it gets hot here. It is usually in the 90's everyday, most of the day and sunny. Driving it at night the temp gauge still goes past the mid point, but not by much. During the day it goes over 3/4 of the way and it seems dangerously close to the white line marking the space before the dreaded red zone of H. Why is it running so much hotter? He said it was safe to drive it at 3/4 of the way over, but it scares me. He said to pull over and shut it off if it gets into the red H zone, of course. I spend all the time behind the wheel now staring at the gauge and praying for it not to move more. Why has it changed? (He replaced the water pump, the thermostat, some sensor, and put in that Red Devil sealant in case the gasket was going.) He didn't really have an answer that was definitive for me as to why it is running hotter. I thought maybe someone here with more experience would know. Is it safe to drive at 3/4 of the way over toward HOT? How can I get it back to the safer middle area? Thanks.
|
|
|
|
|
Replying to: bella14 (Jul 25, 2008 2:14 pm) It might be a good idea to see if you can get the fan to kick in SOONER, that is, at a lower temperature. Changing the type of sensor could help with this. Overheating problems can be a devil to diagnose---very challenging for any mechanic. |
|
|
bella14..... Sounds like I have a very similar problem with my chevy. Was wondering if you would be able to let me know what you have found out and/or what work you have done to fix the overheating. Any help would be greatly appreciated. Thanks. |
|
|
|
|
Replying to: mandi77 (Jun 21, 2005 11:01 am) |
|
You are here:
Forums
Sedans Chevrolet Cavalier Chevrolet Cavalier: Head Gasket Issues
New? Join Now!
Forum Tools
Search Forums
Browse by Vehicle
2005 Chevrolet Cavalier
Browse by Board
Browse by Topic
Today's Chats
