You are here: Forums SUVs Ford Expedition Ford Expedition Rust and Paint Problems

Ford Expedition Rust and Paint Problems

41 messages,  Last post on Dec 02, 2009 at 5:42 AM

You are in the Ford Expedition Forum. Your Hosts are steve_ & tidester

What is this discussion about? Ford Expedition, Paint, SUV

Messages Page 5 of 5 1 2 3 4 5 Prev Next Last

Go To Msg # Search This Discussion

#33 of 41 You have an 8 yo truck and you are upset about rust? by mschmal Jun 16, 2008 (4:33 am)
Just how old does a truck have to be before its allowed to rust?   Did you always do an undercarriage clean after driving on salt covered roads?   Mark Replies to this message: selectusername (Jun 16, 2008 6:46 am)
#34 of 41 Re: You have an 8 yo truck and you are upset about rust? [mschmal] by selectusername Jun 16, 2008 (6:46 am)
Replying to: mschmal (Jun 16, 2008 4:33 am) To be saying this you must either be a Ford representative or have very very low standards (perhaps you've only driven american lemons?)   I can't imagine any consumer accepting rust on a $40,000 vehicle after 8 years and 75,000 miles, at a time when salt is not used on roads anymore.   I have a 1997 Honda CRV that's been driven in the same region and weather conditions, has 140,000 Miles, and doesn't have a spot of rust.
#35 of 41 Re: 2000 Ford Expedition Premature Rusting [ricardop] by charlibob Jul 14, 2008 (2:21 pm)
Replying to: ricardop (Feb 13, 2008 3:07 am) I have a 2001 F150 with very extensive rust on the roof... to the point of going clear through the metal in places. This only started appearing early this year. There is only 48,000 on it, although I guess that isn't a factor. I don't live in an area where salt is used on the road.   I just got the stock answer from Ford that rust is only covered for five years, and that there was no history of complaints about rusting on this line of vehicles. I got two estimates from body shops. One would agree to cut out the dollar size rust spots, there are 8 of them, weld new patches in place, do corrosion treatment, and repaint the top for $1600. The other shop refused to do patches, saying that they would not be satisfactory, and wanted $3000 to replace the roof.   From reading through this thread, it seems Ford has a problem with the rust issue that needs to be addressed, even if out of warranty. Anyone else have some ideas. Replies to this message: wvgasguy (Aug 02, 2008 5:50 pm)
#37 of 41 Re: 2000 Ford Expedition Premature Rusting [charlibob] by wvgasguy Aug 02, 2008 (5:50 pm)
Replying to: charlibob (Jul 14, 2008 2:21 pm) I can understand being upset with the rust mentioned by the previous poster under his vehicle. I can't see however how rust on the roof "snuck up" on you. Dollar sized rust spots going through the metal in less than a year??? Surely there was some bubbled paint or small spots showing up earlier. Do you wax your vehicle?
#38 of 41 2007 Ford Expedition Lift Gate Paint Bubbling by wilson1971 Sep 08, 2009 (12:18 pm)
I have a 2007 Ford Expedition EL and at 37000 miles I have found that the paint is bubbling near the right side of the lic. plate. Ford has rejected the claim numerous times.   Let me know if anybody has experienced this issue. Replies to this message: jkl4 (Dec 01, 2009 5:36 pm) alwaysfords2 (Dec 02, 2009 5:42 am)
#39 of 41 wilson1971 by alwaysfords2 Sep 09, 2009 (5:55 am)
Very common problem. It is an aluminum tailgate so it is oxidation as opposed to rust. Some people have luck getting it fixed at no cost, others are not so lucky.
#40 of 41 Re: 2007 Ford Expedition Lift Gate Paint Bubbling [wilson1971] by jkl4 Dec 01, 2009 (5:36 pm)
Replying to: wilson1971 (Sep 08, 2009 12:18 pm) Have an appt with the dealer to address peeling paint or plastic coated metal panel on the two panels flanking the back lift gate glass on 2007 Nav-L. It is peeling from the top down, no apparent rust. Replies to this message: alwaysfords2 (Dec 02, 2009 5:42 am)
#41 of 41 Re: 2007 Ford Expedition Lift Gate Paint Bubbling [jkl4] by alwaysfords2 Dec 02, 2009 (5:42 am)
Replying to: jkl4 (Dec 01, 2009 5:36 pm) I'd guess they will fix that for you. If it is the same as earlier models, it is an easy panel to switch, they are riveted into the body and with the quarter windows opened you have great access. I had one ripped off my car while it was in transit to me across the country and it was no big deal. It was a bigger deal that the thing held on for a while and gouged the quarter panel. Would have been nicer had it just come completely off.

Messages Page 5 of 5 1 2 3 4 5 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums SUVs Ford Expedition Ford Expedition Rust and Paint Problems