Ask the Car People.SM


Lincoln Aviator Maintenance and Repair

978 messages,  Last post on May 23, 2013 at 6:05 PM

You are in the Lincoln Aviator Forum.

What is this discussion about? Lincoln Aviator, Auto Body, Engine, Suspension, SUV

    
 
Go to NHTSA to file a safety complaint.
 
Or call Monday-Friday (8 am to 8 pm ET) (888) 327-4236 TTY: (800)424-9153

Messages Page 98 of 99

#965 of 978 Re: Injector Service Wash/Flush experience? Cyl 8 prob [bostoncigar] by akirby

Apr 23, 2012 (11:54 am)

Replying to: bostoncigar (Apr 23, 2012 10:07 am)
The failure rate is still relatively low - my guess is way below 10%. You only hear about the ones that fail but there are tens of thousands that never have a problem.
 
Yes, it's a known problem and I would like to see Ford step up with an extended warranty since it's an engineering flaw. But from a business standpoint I understand their position.

#966 of 978 Re: Problem with Lincoln Aviator Gear Shifter [rsego] by gabesounds

Jul 16, 2012 (5:14 pm)

Replying to: rsego (Jun 09, 2009 11:07 am)
Did you ever get a solution to your problem? i am having the same problem
 
Gabe

#967 of 978 Lincoln 2003 Aviator: remote door locks work but not the switches on doors by gabesounds

Jul 16, 2012 (5:18 pm)

I have the ability to lock and unlock my doors with the remote but I can not lock or unlock the doors using the auto lock switches on the door handles.
 
Got any solutions??

#968 of 978 Re: Problem with Lincoln Aviator Gear Shifter [gabesounds] by ginnysmom

Jul 16, 2012 (5:20 pm)

Replying to: gabesounds (Jul 16, 2012 5:14 pm)
The only solution would have been a new engine. I had 11% compression loss on cylinder 8. Sold the Aviator to Carmax and bought a new car.

#971 of 978 hard time getting out of park by walker18

Dec 20, 2012 (7:29 pm)

I have a 03 Aviator and I have to continuously press the brake until I hear a click before I can get it out of park. I had the switch under the pedal fixed (mechanic suggested) still does not work. Also when I’m sitting in park the truck feels like its going to cut off. Any Ideas?

#972 of 978 Fixing/Releasing stuck Lincoln Aviator Gear Shifter [gabesounds] by certifiedmech

Jan 16, 2013 (5:45 am)

Replying to: gabesounds (Jul 16, 2012 5:14 pm)
Lots of stuff written about the problem which is the "brake actuated shifter lockup in park" on Lincoln Aviators is erroneous or more nearly total BS!
The brake light switch on the brake pivot pivot when depressed sends 12v to a cheapo solenoid that pulls a piece of lamp chain on the drivers side of shifter connected to a plastic cam that then gets out of the way of car shifting out of park. All you do is pull the little plastic access panel as described in the owners manual off and you can see it. It can always be unlocked by pushing it forward with a screwdriver. Mine worked intermittently until I pulled the gearshift in out of 1st gear a bunch of times and lubed it took all of 10 minutes. The shifter assembly can be pulled out in half an hour or so using simple hand tools and the manual that shows how to do it costs less than $50 on ebay and their are videos as well. The cam gizmatchie can then be tied or screwed out of the way. USA shifters in San Diego rebuilds these pieces of junk and sells rebuild kit. Again right in the owners manual are instruction on how to release the gearshift with just a screwdriver!!

#973 of 978 Re: Lincoln 2003 Aviator: remote door locks work but not the switches on doors [gabesounds] by kartracer8

Jan 18, 2013 (9:43 am)

Replying to: gabesounds (Jul 16, 2012 5:18 pm)
do the buttons light up when any one of them are pressed?

#974 of 978 Heater blows cold at idle by 04avi

Jan 22, 2013 (5:51 pm)

Ok here is my problem 04 aviator engine runs at constant operating temp and has plenty of fluid. I have flushed the heater cores and replaced the thermostat. Heat only blows hot when engine is at rpm when at idle in driveway at stoplights etc air blows cold. Blend door seems to be operating fine I have read there is a valve in line on one of the radiator hoses but cant seem to find it anywhere. Also bought a heater control valve from auto parts store but havent installed because i cant seem to find where it is supposed to be located. Any suggestions

Messages Page 98 of 99

To POST a message, please Sign In.

Advertisement

Browse by Category

Browse by Vehicle
   View All Vehicles

Browse by Board
Browse by Topic
View All Topics

Edmunds Community

Advertisement