Dealing with sugar in gas tank - READ ONLY

13 messages, Last post on Apr 17, 2002 at 5:52 AM

You are in the Maintenance & Repair - Archived Discussions Forum. Your Host is mr_shiftright

This discussion is ARCHIVED. To reactivate the discussion, post a request in the Lost? Ask the M&R Host for directions! discussion.

What is this discussion about? Engine

Outline

Messages Page 1 of 2: 1; 2; Prev; Next; Last

#1 of 13 Caravan had sugar put in gas tank by royallen Apr 10, 2002 (7:00 pm)
The past 5 days I've been dealing with my wife finding a couple of teaspoons of sugar all around and inside the fuel filler when she gassed up. I had heard as a kid in the 50's that sugar in gas would ruin an engine and was puzzled my wife had driven at least 50 miles with no symptoms. When I talked to my mechanic about steps to take such as towing the vehicle in, etc, I was surprised he and another mechanic recommended doing nothing unless I had symptoms of fuel line blockage as they thought the sugar would not dissolve in gas and would be kept in the tank by the fuel pump intake filter. So I did two things, I had the fuel filter removed and cut it open to inspect it finding no sugar and I obtained test tubes and put 10 cc of gas in one, fuel injector cleaner in one and isopropyl alcohol in one then added two sugar granules. Using a hand magnifying glass I can easily see the sugar crystals still intact in all three tubes after 24 hours. So I now know the sugar does not dissolve in the gas or the additives I use and it is not getting out of the tank. Problem solved and myth of damaging power of sugar greatly diminished (a large amount could certainly clog the fuel pump intake). Finally, if you drive a vehicle without a secure fuel filler like our '95 Caravan - get a locking gas cap.
#2 of 13 locking gas cap! by caesarslegion Apr 10, 2002 (7:07 pm)
you bet,this sounds like my town.kids have nothing better to do than trying to destroy others nice cars.it should be ok.i would get that lock on it today.also keep a light on near your car because vandals like to work in the dark.
#3 of 13 by Mr_Shiftright HOST Apr 11, 2002 (6:21 am)
There are far worse things to put in a gas tank but I'm not going to reveal them for obvious reasons. Let's just hope vandals keep thinking sugar is deadly. Probably the worst thing that can naturally happen to a car's fuel system is rust or water, both of which might require dropping the gas tank and possibly replacing the injectors.
#4 of 13 I'd keep that test tube experiment going by opera_house_wk Apr 11, 2002 (9:29 am)
I think I saw in another post that the reaction took a couple weeks.
#5 of 13 For what it's worth... by csandste Apr 11, 2002 (2:52 pm)
Click and Clack deal with sugar (not that serious)... http://cartalk.cars.com/Columns/Archive/2001/February/02.html Modern Maturity (auto myths) http://www.aarp.org/mmaturity/jan_feb01/consumer.html Straight dope (could clog) http://www.straightdope.com/mailbag/msugargs.html 2Car Pros (injectors probably plugged)... http://www.2carpros.com/topics/gastank.htm
#6 of 13 by Mr_Shiftright HOST Apr 11, 2002 (3:50 pm)
If you put enough of anything in a gas tank it will foul it up. I'm sure Cheerios are as deadly as sugar. (and you can add milk, too!)
#7 of 13 sugar in gas tank by royallen Apr 11, 2002 (5:53 pm)
Thanks for the informative posts. o_h_w, I'll keep the test tube tests going and will follow-up in a couple of weeks. My last concern is that water condensation in the tank will dissolve some sugar. My strategy is to add 1/2 oz isopropyl alcohol with each fill up to dilute and minimize the sugar load downstream. I also plan to inspect a spark plug at the same interval to look for fouling. I'm also a little concerned that fuel injector contamination from sugar water/alcohol could be hard to clean since water can't be used - at least not in the usual way.
#8 of 13 You should try to NOT let sugar dissolve in water.. by zr2rando Apr 12, 2002 (3:12 am)
If it dissolves in water then it will go through the filter (filter should stop water too but some still dissolves into the gas, especially when you use the water remover/alcohol/dry gas etc) and harden/plate out like laquer/glaze in the injectors/intake valves and is almost impossible to clean except by physical(abrasive) action. Keep it solid and let the filter catch it...just change the filter is alot easier... Years past I have always seen that sugar in the tank really had to have tank removed and rinsed/dried, fuel lines air blown in reverse to really clean it right. Best thing is to find the people responsible and watch them do the work. good luck
#9 of 13 FLUSH YOUR TANK NOW by pblevine Apr 12, 2002 (9:12 am)
Why take a chance? I'd even drop the gas tank. And remember, "Equal" is better than sugar! In coffee, that is. Never in your tank.
#10 of 13 Hey as a 5 year old I discovered by mrdetailer Apr 12, 2002 (1:36 pm)
that dirt can really clog up a tank, having deposited several handfulls in one myself. Dad definitely was NOT happy. Seriously, I would drop and clean the tank immediately. The cost of that repair isn't bad compared to the dangers it can cause.

Messages Page 1 of 2: 1; 2; Prev; Next; Last

New? Join Now!

Forum Tools

Search Forums

Browse by Vehicle

Browse by Board

Browse by Topic

View All Topics

Today's Chats

Chat Schedule