Last post on May 21, 2013 at 11:24 AM
You are in the Ford Expedition
What is this discussion about?
Ford Expedition, SUV
Go to NHTSA to file a safety complaint.
Or call Monday-Friday (8 am to 8 pm ET) (888) 327-4236 TTY: (800)424-9153
#1897 of 1936 Fuel tank pressure problem? maybe?
Aug 04, 2011 (9:39 pm)
i have a 2000 ford expedition, lately when driving it, it has started to cut out and die. By chance we found that by taking the gas cap off, it idles back up and runs fine. it is getting to be an issue, we ran diagnostics with no clear answer, replaced fuel pump, cleaned the valve lines coming out of the tank, peplaced some valve under the hood? (not sure why, but thats what the parts house suggested) We can not seem to figure it out! Another weird thing is that we drove it about 50 miles in the rain (cool outside) and it never even stuttered, but later that day when it got hot, it did the same thing again. It dies and wont start unless you open the cap. What can it be?
Aug 11, 2011 (11:20 am)
My 2001 Expedition surges as soon as I start it. The ABS lights comes on, the speedomitor (sorry sp) and RPM move up and down, the radio cuts in and out, and the windows are difficult to roll up. This has been happening for the past few months and at one point it stalled and would not start. I heard a tcking sound at that point and this has not happened again. Please tell me what I can do!!!
#1901 of 1936 2005 Ford Exp clicking noise when driving
Aug 16, 2011 (4:12 am)
Hello, We have a Ford Exp and for the past few months we have noticed a clicking noise when driving. The noise will get faster as we accelerate. The oil is fine and has even been changed again recently. Any clue what can be causing this?
#1902 of 1936 Re: 2005 Ford Exp clicking noise when driving [tinamj]
Aug 16, 2011 (9:39 am)
Have a mechanic check it out, could be a valve.
First thing to do is to find out whether it is inside the engine, or outside. Disconnect the serpentine belt and start the engine. If the ticking is still there, it's inside the engine. If the noise has stopped, then the problem is one of the externally mounted devices (e.g. alternator, AC compressor, etc).
#1903 of 1936 Re: 2005 Ford Exp clicking noise when driving [kiawah]
Aug 16, 2011 (11:09 am)
Thanks so much for answering, I took it to a auto place on post (we are in Germany right now) but they didn't know what it was and didn't feel comfortable looking into the engine so they told me to take it to a Ford Dealership. If it is inside the engine is it something serious that may cost a lot of money?
#1904 of 1936 Re: 2005 Ford Exp clicking noise when driving [tinamj]
Aug 16, 2011 (11:32 am)
Has the potential to be expensive. Since no-one can hear your engine over the internet or do any of the diagnostic techniques that a mechanic can....it's hard to know. Could be something relatively easy to fix......or it could be a major problem that could turn catastrophic if not corrected.
As an example, if you have a piston rod bearning going bad, they'd have to open up the engine to fix it, which would be expensive. If on the other hand you drive it and the bearing totally fails and the rod punches thru the engine block, then it's catastrophic and you will need a new engine. If it is something external to the engine, would be cheaper.
Point is, nothing to fool around with, get a trusted/competent mechanic to figure out what the problem is.
#1905 of 1936 Re: 2005 Ford Exp clicking noise when driving [kiawah]
Aug 16, 2011 (11:35 am)
Thanks so much. I have an appointment with Ford Monday, so I hope it is something not to major.
I really appreciate you taking the time to answer my question
#1906 of 1936 Re: 03 Expedition with noise coming from rear [airborne6]
Sep 28, 2011 (6:05 pm)
I have this problem with my expedition too. It is an 04. I had that popping noise that has now advanced to something like the sound of a machine gun. However, it started out just like the pop noise you described in this post. Did you ever find out what the problem is?