You are here: Forums SUVs Ford Expedition Ford Expedition Maintenance and Repair

Ford Expedition Maintenance and Repair

1827 messages,  Last post on Nov 27, 2009 at 1:19 PM

You are in the Ford Expedition Forum. Your Hosts are steve_ & tidester

What is this discussion about? Ford Expedition, SUV

Messages Page 179 of 184 1 ... 176 177 178 179 180 181 182 ... 184 Prev Next Last

Go To Msg # Search This Discussion

#1774 of 1827 Re: Rear Ventilation system click and whump sounds [jg88] by bronsonb Jul 14, 2008 (11:09 am)
Replying to: jg88 (Jul 10, 2008 8:36 am) I had this same problems, and as the other poster mentioned, it was a relatively simple repair. I actually removed the entire cover in the back seat area. It required a special "star socket" to remove the second row passenger side seat belt anchor, and then the rest of the plastic cover on that side popped out with a little prying (might be a screw under the plastic cover above the bumper that needs to be removed too).   The two units that are the culprits are about 1/2" thick, squarish in design and about the size of a pack of cigarettes (but a bit larger). They are held in by a few screws and a simple plug. As the previous poster noted, unplug one and see if the sound goes away.   I ordered replacements online, but you could probably get them from your local Ford store too. One of the actuators costs about $18, but the other was almost $40. Overall it was an easy repair considering I'd seen posters who said they paid $400 to get that fixed.   Good luck.
#1775 of 1827 Re: 2004 Expedition, NBX [wichezer] by jantj5 Jul 17, 2008 (5:12 pm)
Replying to: wichezer (Mar 31, 2006 5:52 pm) I have the same problem. Did you find a solution?
#1776 of 1827 Cooling fluid leak above my starter moter by genoah Aug 09, 2008 (11:23 am)
I have a 97 Ford Expedition 4.6 V8 with a really bad leak, there’s cooling fluid really pouring out of a spot that I cannot exactly see above the starter motor. The hoses and lines seem intact and there’s no water in the oil and it runs ok as long as I keep topping up. Any help or advice would be lovely, Thanks, Jessica
#1777 of 1827 Re: Blown out Spark plug [zman3] by woodye Aug 11, 2008 (8:03 am)
Replying to: zman3 (Mar 06, 2006 11:18 am) There is a spark plug removal problem in the 5.4 Liter engine. The plugs have a long shank below the threads in a tight hole in the head going down to and open to the combustion chamber. Carbon and combustion crud builds up around the shank below the threads and locks the plug in place. Forcing the plugs can strip the thread since they may not be strong enough to break the buildup.     I called a lot of Ford mechanics and finally may have found the solution. On a Warm Engine, (most Ford Service reps said Cold engine, wrong!) losen the spark plug 1/4 to 1/2 turn.   Then spray carb cleaner around the plug. It goes around the threads and breaks lose the carbon and crud build-up around the long shank of the plug.    I replaced my plugs using this procedure and everthing worked OK. You can hear the carb cleaner bubbling/sizzling, and the plugs came out fine. I used a magnet to pull them out of the head recess and had to wiggle a couple of plugs. Still a pain and knuckle busting job; but, didn't break any plugs.    Champain makes a one piece plug, the stock plugs appear to be a bonded two piece shank. They are expensive and may not be necessary with the above procedure with a stock plug.   If you have already stripped the threads, I understand Car Quest has a good kit with a hela-coil to replace the threads, if you can get the broken shank out of the head.  Woody
#1778 of 1827 Back Up Aide by colleenbrew Aug 13, 2008 (7:34 am)
I have a used 2003 Ford Expedition and for some reason, the check back up aide message comes on each time I go into reverse, however, the back up beeping noise has only come on once. I have no idea where this sensor is located, or how to go about even fixing something like this. The previous owners did tow a camper, so I think it may have been disconnected, if this is possible. Does anyone know how to find and/or fix this problem? Replies to this message: 9729 (Nov 18, 2008 10:45 am) colleenbrew (Nov 18, 2008 11:09 am) 9729 (Nov 19, 2008 6:33 am)
#1779 of 1827 Re: having problems with gear shift [ironmac1] by txhill4 Aug 18, 2008 (2:35 pm)
Replying to: ironmac1 (Mar 14, 2006 3:44 pm) We have a 2004 expedition that is doing this exact thing. Where did you find the info to fix it. Any help would be great!
#1780 of 1827 2000 ford expedetion by stephqua Aug 30, 2008 (12:10 pm)
my gear lever will not go into park and to turn my truck on i have to put it in nuetral
#1781 of 1827 2007 EB EL by iontrap Sep 06, 2008 (1:10 pm)
I'm seriously considering buying a used 08 EB EL RWD with 16,800 miles. Are there any problem areas with the new generation of Expeditions? Replies to this message: dieselone (Sep 10, 2008 7:45 am)
#1782 of 1827 Re: 2007 EB EL [iontrap] by dieselone Sep 10, 2008 (7:45 am)
Replying to: iontrap (Sep 06, 2008 1:10 pm) I purchased a used 07 EB 4wd Expedition back in June. The only issue I've run into is poor shifting with the 6speed transmission (slow to downshift to 1st when coming to a brief dead stop, it would stay in 2nd gear, unless stopped for several seconds). I don't know if it affects 2008 models or not. I had the dealer perform a TSB to reprogram the module that controls the transmission and that fixed the problem. So far I really like the Expe.
#1783 of 1827 03 XLT Stalls on initial start up by msmonique Sep 14, 2008 (5:42 am)
my 03 xlt has recently started to stall upon initial start up, when i first turn the truck on when it's cold or has been sitting for a while, it hesitates to start, but then kicks over after a few seconds, and if i turn the truck off right after the hesitant initial start up, and start it up again, it doesnt hesitate to start, and it starts right up just fine. HELP, Any Ideas?????

Messages Page 179 of 184 1 ... 176 177 178 179 180 181 182 ... 184 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums SUVs Ford Expedition Ford Expedition Maintenance and Repair