You are here: Forums Vans & Minivans Ford Aerostar Ford Aerostar

Ford Aerostar

520 messages,  Last post on Nov 16, 2009 at 4:57 PM

You are in the Ford Aerostar Forum. Your Host is Karens

What is this discussion about? Ford Aerostar, Van

Messages Page 2 of 52 1 2 3 4 5 6 7 ... 52 Prev Next Last

Go To Msg # Search This Discussion

#10 of 520 isotope by isotope May 30, 1998 (1:55 am)
Oh, I forgot: About 18 months ago I had to replace the power steering. That was expensive too. But I agree with what others have said. I really like my Aerostar and all the room it has. I can fit two full-size bikes upright in the back of my extended van. You can't do that with any other van. I wish they still made it. good luck with your van. Just set aside about $100/month for repairs and you'll do fine.
#11 of 520 Goldgary by Goldgary Jun 08, 1998 (2:17 am)
I will keep you posted. I have the 4.0 V6 engine. Not sure if this is better or worse. I have had the ball joints and brakes done, drive axels, U-joints and stabelizer bar replaced, shockes also. Had it alinged. Still has a vibration, more noticeable at higher speed. Getting it checked out this week. How has the rust been on yours. The bottom half has all be redone. Touches of rust beginning to come up from underneath. I will wait till later to adress that. What specifically on the A/C went?
#12 of 520 dean42 by dean42 Jun 12, 1998 (11:36 pm)
I have a friend who has a '93 Aerostar that caused her to wreck when the cruise control engaged itself and accelerated through a stop sign (from a stop, could not brake it.) Has anyone else had or heard of this problem? She needs to know if Ford knows, also. Thanx.
#13 of 520 birkiebob by birkiebob Jun 15, 1998 (6:00 pm)
I have a '92 awd XLT extended with tow package with 120k miles. Just starting to look for a replacement for in a year or so and having a hard time finding something a little downsized with the same towing capacity! I tow a 2500# camper and the 4.0 v6 is low on hp but high on torque for towing. I've had u-joints, a thermostat and brake rotors replaced. Otherwise just routine stuff, but it does have a chronic oil leak that looks like valve covers, about a qt per 1k, and requires premium gas now or pings consistently. I can afford the oil and gas at this point, and have tried tightening the covers but they are hard to get to (have to go through the doghouse and fender well for a couple bolts--like changing plugs). My tech also told me to put a can of fuel system teatment through the tank every 5k or so (just before an oil change). This has been a real workhorse of a vehicle that rides exceptionally well on the highway for a truck! And I never, ever get stuck in the Wisconsin winters. Goldgary: The awd transfer case does vibrate some naturally - I've never had a problem with it. I have seen the same case on full-size Econoline Vans (not sure if factory) with V8s so it must be pretty strong! The brakes are a little weak when towing, especially in the Rocky mtns, and I've put brakes on my trailer to help. I may be looking for a '97 if none of the new minivans stack up. Wish they had improved them some, with four doors, the new v6, etc. Explorers are just too small and no better gas mileage...go figure??? Eel: Was the Windstar really a lousy tower? Did you have it properly set up? Thanks, Bob
#14 of 520 mrwho by mrwho Jul 22, 1998 (2:29 am)
I am considering purchasing a 1995 xlt with electronic awd. The awd has me a little nervous but not sure why. Maybe cost of repairing or failures. Any feed back on this vehicle would be greatly appreciated. Thanks! Mark
#15 of 520 lge by lge Aug 07, 1998 (11:23 pm)
i put 75,000 miles on a 92 xlt with 3.0 engine and the only repair was to recharge the a/c two times. my 95 xlt with 4.0 has 45,000 miles . the a/c has been charged once. the check engine light comes on ocasionaly but that is the only problem
#16 of 520 bob34 by bob34 Aug 11, 1998 (2:50 am)
We have a 1995 Aerostar with 35,000 miles on it. It needs an overhaul on the Automatic transmission. Is this normal and has there been problems with these transmissions?
#17 of 520 Jan by jan8 Aug 13, 1998 (9:16 pm)
I have a '92 Aerostar XLT with low mileage that I LOVE, but the A/C is GONE! I have heard of this happening to MANY Aerostar owners. I know it is no longer covered under any warranty, but has anyone had any luck in getting Ford to do anything about it? It's really HOT where I live and I can't afford any major repairs!
#18 of 520 KAURELIO by KAURELIO Aug 14, 1998 (4:02 pm)
I have a '89 Aerostar XLT extended length. We have 162,000 miles on it and it still runs strong with the 3.0 V6 and 4sp auto. We have had to replace the water pump and power steering pump once. Had the computer go out just before the warrenty expired at 50,000 miles. We have had to have alot of work done on the dual a/c, it still doesn't cool the best on a hot day (we live in Georgia). I have also gone through several upper radiator hoses and recently replaced a heater hose. Also had the front brake calipers rebuilt and the brake proportioning valve replaced. Other than that it has been routine maintenance. We love our van and I would buy another if they still made them. I want to see how many more miles I can get on this baby before it dies. (Power windows need to be fixed now). Kevin
#19 of 520 Harold by Mustang10 Aug 17, 1998 (5:10 am)
Some advice.....AVOID BUYING AN AEROSTAR AT ALL COSTS. They have an old dated body, poor resale value, loud engine, poor ride, unreliable, and poor build quality. If you must get a used Ford van, go for the 95 or 96 Windstars. If you want a van to pull a big boat, at least get an Astro or a SUV. Aerostars are pure junk.

Messages Page 2 of 52 1 2 3 4 5 6 7 ... 52 Prev Next Last

Go To Msg # Search This Discussion

You are here: Forums Vans & Minivans Ford Aerostar Ford Aerostar